Body problems of the 2004 Dodge Ram 1500

21 problems related to body have been reported for the 2004 Dodge Ram 1500. The most recently reported issues are listed below.

1 Body problem

Failure Date: 11/16/2020

Water is leaking into the cab from the grab bar located on the "a" pillar on the driver's side. I have researched this issue and there is a technical service bulletin (TSB #23-003-04) for this problem, which was issued for many model years of this type vehicle.

2 Body problem

Failure Date: 07/14/2016

The contact owns a 2004 Dodge Ram 1500. While driving approximately 20 mph, the driveshaft detached from the rear of the vehicle without warning and the rear axle locked up. The vehicle was towed to the dealer where it was diagnosed that the pinion nut detached from the vehicle. The vehicle was not repaired. The VIN was excluded from NHTSA campaign number: 14v796000 (power train). The manufacturer was notified. The approximate failure mileage was 150,000.

3 Body problem

Failure Date: 10/24/2015

Tl- the contact owns a 2004 Dodge Ram 1500. The contact stated that while approaching a stop light the front drivers side wheel bearing seized and fractured with no warning while at a low rate of speed. The front fender was damaged, the drivers side hub assembly and the front drivers side tire was destroyed when the failure happened. The vehicle was towed to the contacts residence and was to be inspected and diagnosed to determine how this failure happened. The manufacturer was notified of the failure and the concern with scheduling the two air bag recall repairs. The approximate failure mileage was 71,000. Parts distribution disconnect dyd.

4 Body problem

Failure Date: 08/01/2015

The contact owns a 2004 Dodge Ram 1500. The contact stated that the vehicle experienced severe corrosion. The vehicle was taken to an unknown Ford dealer where it was diagnosed that the frame would need to be replaced. The manufacturer was not notified of the failure. The failure mileage was approximately 155,000.

5 Body problem

Failure Date: 06/02/2015

Severe rust and corrosion on body and suspension parts. Started at around 10 years of age. Support for bed to frame shows severe corrosion making hauling unsafe. Water is able to enter the cab through corroded rocker panels causing mold. Also, electrical system malfunction in throttle body can cause no response from accelerator at intermittent times.

6 Body problem

Failure Date: 06/01/2015

Tl-the contact owns a 2004 Dodge Ram 1500. The contact stated that NHTSA campaign number 15v313000 (air bags) had an exceeded a reasonable time for repair. The contact received the recall notification over five months. The dealer continued to advice that the parts was not available for repair. The contact also wanted to state that the dash board material was defective causing the entire dashboard to fracture. The vehicle was not repaired. The manufacturer was not notified. The failure mileage was 60,000. Li.

7 Body problem

Failure Date: 04/20/2015

The contact owned a 2004 Dodge Ram 1500. While driving approximately 35 mph to exit the highway, the rear driver side tire completely fractured. The vehicle spun around and crashed into a wall. The vehicle was destroyed. None of the air bags deployed. A police report was not filed and there were no injuries. The contact inspected the vehicle and noticed that there was extensive rust and corrosion on the frame. The vehicle was towed to the contact's residence and then towed to a repair shop. The manufacturer was not notified. The VIN and failure mileage were not available.

8 Body problem

Failure Date: 09/11/2014

There is extreme rust out on my Dodge ram above the rear wheel well. This is on the box of the truck. The Dodge trucks are rusting from the inside out. There is foam material behind the body. Once this material gets damp or wet, it starts rusting the vehicles from the inside out. My truck only has 82,000 miles and is rusted completely thru the outer metal. This is weaking the integrity of the body. I did talk to a body shop and they have to cut the body, remove the foam and rust and weld a new patch panel in place.

9 Body problem

Failure Date: 02/05/2014

Oncoming vehicle lost control came across 4 lanes to hit front of truck. Dodge is totaled but air bags did not deploy. I contacted Dodge to have them check them out and was told, first a special task force would come check the airbags and we would be compensated, then later was told due to the age and mileage of my truck they wouldn't but I could take it to a Dodge dealership and see if they would run the test at my expense. Dodge didn't seem to care why air bags didn't go off since the truck is 10 years old.

10 Body problem

Failure Date: 12/12/2013

Another single driver vehicle ran a stop sign and the single driver Dodge hit the driver's door directly and deployed both front air bags and totaled both vehicles. The drivers air bag launched metal into the left wrist and forearm of the driver while his hands were in the 10 and 2 o'clock steering wheel positions. The left wrist lacerations and large hematoma required hospital care and left scars. The driver also suffered lower back damage requiring surgery. The truck was totaled in January 2014 and sent for salvage. On December 15, 2014 I received a Chrysler safety recall (p40/NHTSA 14v-354) on the air bag inflators of the 2004 Dodge Ram 1500. The problem in the recall notice is described as; “excessive internal pressure, during airbag deployment events, could result in an increased chance of occupant injury during certain crash conditions. ”.

11 Body problem

Failure Date: 12/08/2012

The contact owns a 2004 Dodge Ram 1500. While stationary, the vehicle's fenders above the wheels were severely rusted. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was 91,000.

12 Body problem

Failure Date: 08/27/2012

Drivers side door lock is stuck in the down position and cannot be unlocked from outside even with key. Remote does not work either to unlock door. Very dangerous with possible children and/or pets inside the vehicle in 100 degree texas heat!.

13 Body problem

Failure Date: 08/27/2012

Tl- the contact owns a 2004 Dodge Ram 1500. The contact stated that there were two small bubbles in the paint above the rear tire well. Upon further investigation, she noticed that the rear boxes above both rear wells were completely rusted. The vehicle was taken to the dealer for diagnosis and the contact was informed that both panels on the rear box would need to be cut and replaced. The manufacturer was notified of the failure. The vehicle had not been repaired. The failure and current mileage was 53,000. Kmj.

14 Body problem

Failure Date: 12/13/2011

The contact owns a 2004 Dodge Ram 1500. The contact stated that the front driver's door would not unlock. The contact also stated that he could only enter the vehicle using the remote entry on the remaining doors. The vehicle was not taken to have the failure diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was 94,000.

15 Body problem

Failure Date: 10/03/2011

The contact owns a 2004 Dodge Ram 1500. The contact stated that the driver side door lock was jammed and the key could not be inserted into the manual key lock. The vehicle was not inspected by a dealer nor repaired. The manufacturer was contacted and they offered no assistance. The failure mileage was approximately 36,000. Updated 11/29/11 the consumer stated the door actuator was replaced. 12/07/11.

16 Body problem

Failure Date: 02/01/2011

The front doors leak air really bad going at highway speed you cannot carry a conversation with out yelling. Took it to dealer and they said it needed new door seals because of normal use and how old it was and the amount of miles on it had made the seals no longer working properly. I told them I had a 1996 with 210,000 on it and you could hear a pin drop it was so quite. They charged me $60 and did nothing for my problem!!.

17 Body problem

Failure Date: 04/02/2010

Both rear quarter panels right above the wheel wells started bubbling. Then after the paint pealed there was nothing but rust. Happened on both sides at the same time.

18 Body problem

Failure Date: 08/03/2009

My 2004 Dodge ram driver side stop working my keys got lock inside the only way to open is by using the remote and climb through one of the other doors which now it is impossible since none of my doors open anymore specially the driver door that it is supposed to open either with the original key or the remote which I can't do either, this is very frustrating because I am an older woman and can't be climbing through my window to do perform this. Please help ## VIN passed ## Dodge ram pickup 1500 2004 ##.

19 Body problem

Failure Date: 11/19/2004

Dodge Ram 1500 year 2004 purchased brand new on March the vehicle had 22 miles on it when the accident occured it had approx. 10,000 miles. Proble defective axle and or rim. Note: previous tire blow out rim totaled and repaired that rim was placed on the truck and the tires rotation and that rim went to the left rear axle, tire is lost.

20 Body problem

Failure Date: 07/24/2004

I originally reported this accident to NHTSA website and I'm not able to find the complaint because the website has change. The accident happened in cusseta, GA, the truck made a loud noise on the left side an hour before started spinning out of control, and it did it again before the accident. The truck was deemed total and the mechanic from the wreckage company said the axle broke. I reported this to Dodge/Chrysler and they sent an investigator to check the truck and he said to me "I was lucky to be alive" Dodge/Chrysler never game me no information at all, I was actually brush aside like nothing. Please help me find the original complaint I submitted.

21 Body problem

Failure Date: 05/01/2004

Tl-the contact owns a 2004 Dodge Ram 1500. The contact stated that the front driver and passenger side grip handle failed when pulled. The contact noticed that the screws that hold the handle in place, which is inside a plastic sleeve is not strong enough when a occupant is pulling themselves in the vehicle. The failure recurred multiple times. The vehicle was taken to the dealer and they replaced the handles. The failure recurred and replaced multiple times. The manufacturer had been notified of the failure. The approximate failure mileage was 10,000. Gb.


Other Structure related problems of the 2004 Dodge Ram 1500


Ram 1500 Service Bulletins
Ram 1500 Safety Recalls
Ram 1500 Defect Investigations