Transfer Case Problems of Ford Escape Hybrid

Vehicle displayed "service emissions system" warning immediately after driving off the lot. After replacement of all emissions parts, vehicle still intermittently displays this warning and occasional "stop safely now" messages causing the engine to shut down. Vehicle also displays "service brake system" warnings daily despite having entire breaking system replaced causing failure of abs breaking system resulting in brake pedal going all the way to the floor and taking a much longer distance to stop while driving. Vehicle surges forward while stopped at traffic lights increasing the risk of a crash. Vehicle displays "passenger door ajar" warnings although door is shut. This results in alarm and lights flashing constantly resulting in several drained batteries so vehicle does not start. Transfer case or "power take off unit" failed at 125k miles resulting in non-drivable condition.

See all problems of the 2007 Ford Escape Hybrid 🔎.

The power takeoff unit, also known as the power takeoff assembly, and or the transfer case has gone bad . Ford says that the part cost $3700. . While talking with several repair shops in my area, they state that this is a very common problem with this tvehicle. If it is true that this is a common problem ,why hasn't it been recalled recalled. It sounds like a bunch of marbles are rolling around in my transmission while coasting.

Started with occasional clunking when in reverse. Slowly developed a sort of thumping like when driving. Like from a bad tire or wheel bearing. As my wife had a medical problem, I drove it for about a week before checking out. I rotated and inspected the tires and breaks. I manually rotated each wheel by hand to check for signs of a wheel bearing problem. Nothing found. The next couple days the noise became worse. I took it to a reputable transmission shop. When they test drove it, they would not even take it off their lot. Their comment to me is that they hope I had not been driving it long like this. They were sure that something in the trans axle was about to lock up. I am sure they were right. By this time it was quite bad. They found that my transfer case had failed at 40,245 miles. A little research on the internet shows that this is a common problem with awd escapes. I notice that 2 were reported to the NHTSA, one resulting in injury. If this unit locks up while driving, loss of life is possible. Only a small percentage of escapes are awd and have transfer cases. It appears that a high percentage of early awd escapes are suffering from this problem. Any drive train issue in any vehicle which could result in the vehicle locking up while under way should not happen. Ford has a responsibility to fix this issue. I have to admit that when I drove the car to the shop that morning it sounded so bad that I was a little scared to drive it faster than around 30 mph. It would have completely failed within days. I feel I was lucky to get it repaired when I did. It cost me $4,353. 00 to replace the transfer case. Now I am not sure I want to keep the vehicle. Not sure I should trust their cvt either.

My husband and I when returning home from a visit to relatives in taylorsville, utah. It had been snowing but had stopped or slowed down in taylorsville. Since we were driving an Escape Hybrid 4-wd, we believed we would be fine to begin our trip. We were driving on interstate 15 when it started snowing really hard. We were just past the provo area. There were many cars and big trucks on the freeway and everyone was driving as slow as possible. We were driving in the slow lane when suddenly the car started to slide into the inside lane. We had not made any sudden moves, had not increased speed or applied brakes. I could not understand why we began to slide as if the 4-wd kicked in , as it should had. We should have had the necessary traction. It did not feel as though we had any traction at all. As we slid to the inside lane we continued sliding on an angle toward the shoulder. When we reached the shoulder the car rolled onto the passenger side. I was amazed as both myself and my husband grew up in snow country and had many years of experience in driving in the snow. I never had a vehicle suddenly start sliding unless I was trying to turn a corner, stop at a light/stop sign, or made some other action which changed the movement of the car. I have never rolled in a car, but I have slid onto the shoulder on a few occasions. I did not believe the Smart 4- wd system was working properly, and I did not believe we should have rolled.

See all problems of the 2006 Ford Escape Hybrid 🔎.