Car Stall problems of the 2005 Ford Excursion

Tl the contact owns a 2005 Ford Excursion. The contact inquired about a recall and was informed there were none. While driving 65 mph, the vehicle stalled without warning. The vehicle was taken to an independent mechanic. The contact called a local dealer (chapman Ford, 9371 roosevelt blvd, philadelphia, PA 19114) and was advised to schedule a service appointment. The vehicle was not diagnosed or repaired. The manufacturer was notified and referred the contact to NHTSA. The failure mileage was 192,000.

The contact owns a 2005 Ford Excursion. While driving at an unknown speed, the vehicle stalled, shut off, and the check engine warning indicator illuminated. The vehicle was towed to the contact's residence. The dealer was contacted (buss Ford, in mchenry, IL) who stated that there was no recall. The manufacturer was made aware of the failure and stated that there was no recall. The failure was not diagnosed. The failure mileage was approximately 120,000.

The contact owns a 2005 Ford Excursion. The contact stated that the vehicle stalled without warning. After several attempts, the vehicle was able to restart, but the failure recurred. The vehicle was not included in NHTSA campaign number: 05v270000 (electrical system). The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The approximate failure mileage was 150,000. . . . . Updated 07/22/15.

The contact owns a 2005 Ford Excursion. The contact was driving 5 mph when the vehicle stalled without warning. The vehicle was taken to the dealer for inspection but the dealer was unable to diagnose the failure. The vehicle was not repaired. The manufacturer was made aware of the issue. The approximate failure mileage was 125,165.

Spark plug blown out of head of vehicle, brought to dealer and was told it was not covered by warranty because the plug had loosened ,these plugs were factory installed therefore it should be considered defective workmanship and should be covered under warranty. This problem is a common occurrence with Ford motors as I have been made aware. I have also reviewed many articles relating to this several of which are quite disturbing mainly the fact that there have been instances of spark plugs ejecting and rupturing the fuel line which sits directly above the spark plug causing a fire and engulfing the vehicles in flames. Being as I have a large family we have a Ford Excursion and we have children strapped in car seats I am quite concerned that this is even a remote possibility and I feel that this should be a grave concern for your organization as well. Bottom line is Ford has an engineering problem with these motors and needs to be held accountable and correct them.