Five problems related to diesel engine have been reported for the 2005 Ford Excursion. The most recently reported issues are listed below. Please also check out the statistics and reliability analysis of the 2005 Ford Excursion based on all problems reported for the 2005 Excursion.
The contact owns a 2005 Ford Excursion. While driving 15 mph, the contact noticed that the vehicle suddenly stalled without warning. The vehicle had not been repaired at the time of the complaint. The current and failure mileages were 61,463. Updated 7/26/10 updated 07/29/jb.
The contact owns 2005 Ford Excursion diesel. The contact stated that while driving 60 mph, the vehicle began smoking and stalled. The contact attempted to restart the vehicle but to no avail. The vehicle was taken into a local repair shop and diagnosed as a faulty engine. The vehicle was repaired. In addition, the contact stated that every time the heater or air conditioner was activated, fumes would emit into the vehicle. The failure mileage was 176,000 and the current mileage was 179,000. Updated 2/28/11 updated 04/29/11.
Was traveling approximately 65mph on the freeway merging onto another freeway when the truck suddenly stalled. There were no brakes, no steering, and the truck would not restart. We had four children with us, three of them small and in car seats. We had to transfer the children into a tow truck with moving traffic on both sides of us. It was a very dangerous situation, that could have resulted in a major accident causing major trauma or death. Ficm is good, we are still trying to figure out the problem, but could possibly be the high pressure oil pump. This 6. 0l diesel engine should be recalled and fixed by Ford. This issue has been addressed with pick-ups and vans, but not the Excursion.
Diesel engine, vehicle will on occasion fail to start. Engine will turn over but it seems no fuel gets to engine. Gas pedal module and assembly have been replaced 5 times with the problem continuing.
2005 6. 0 diesel Excursion has had many motor issues and lots of parts already replaced by Ford up to this date. Turbo quit working while driving and had to be replaced in may, 2007. In June, 2007, vehicle has more turbo issues and egr cooler assembly is replaced. On July 4th, 2007, vehicle starts stalling while driving down freeway and wiring harness had to be replaced. On July 16th, 2007, (3 days home from shop), stalls again while driving down freeway. Dealership cannot determine problem yet refuses to buy back defective vehicle. It's been over 60 days in shop since bought brand new in 2005. Oasis report is 6 pages long already.