Check Engine Light On problems of the 2016 Ford Explorer

Began feeling very sick on Friday January 5th, car had bad exhaust smell. Headache, dizziness, nausea, this continued over the weekend so much so that I did not drive anywhere Sunday from 1:00 on or at all on Monday. Woke up Tuesday feeling ok and drove my car to work, while driving the 4 miles on the fwy to get there my car started smoking profusely from the exhaust pipe. I immediately took it to Ford, it is still there. They are refusing to pay for repairs, they say turbo engine and engine need repair/replacement. Could this have to do with the exhaust issues I see people keep having? never once did the check engine light come on since I've owned the vehicle (2 yrs, 2 months) could there really be that much wrong with the car without even a hint there was an issue and no check engine light?.

This has happened twice now, when driving on the highway (with no warning or any check engine lights on) the engine will suddenly stop, a notice to "check manual" plus a wrench light will come on. The vehicle will not accelerate, forcing you to coast or stop on the side of a road/highway. Vehicle has less than 14,000 miles on and has had maintenance and oil changes regularly. ).

Was traveling on I-96 at 60-65 mph fairly heavy traffic in the left center lane. The wrench light and check in light came on and loss of acceleration. Luckily was able to move to the left shoulder without incident. The engine was running very rough and I shut the engine off. The wrench light message gave a message to check manual. I started to call for roadside service and was on hold for a short amount of time. I hung up and tried to start the car as I was approximately a mile from the next exit. I was able to start the car. The wrench light was off but the check engine light remained on. I was able to get the car to accelerate normally and decided to try and get to the next exit. I was able to cross to the right lanes but the same thing happened and was not able to make it to the exit but at least I was on the right shoulder. My opinion is that this issue could be a big hazard. I was fortunate to have traffic that was light enough to allow me to maneuver but if this were to happen while making a left hand turn across traffic, heavy traffic or close following traffic this could have been a bad accident.

The contact owns a 2016 Ford Explorer. While driving approximately 60 mph, the vehicle lost power and stopped. The check engine light and a wrench indicator illuminated. The driver pulled over and restarted the vehicle after about ten minutes. The vehicle was towed to a local dealer where it was diagnosed and the throttle body was replaced. The manufacturer was made aware of the failure and informed the contact that NHTSA would be notified. The failure mileage was 14,000.

Driving down road and Explorer started losing power, cutting out and engine almost died. The check engine light and tool light came on display. I was barely a few hundred feet from my house, so I slowly managed to get vehicle to my driveway. My husband attempted to drive Explorer in subdivision again and Explorer again started misfiring and engine died. Turned air conditioner off and it restarted and appeared to shake Explorer as engine misfired and we barely got it back in our driveway. It only has 7,740 miles on it!! I called dealership and had it towed to there today.

The contact owns a 2016 Ford Explorer. While driving 60 mph, the accelerator pedal was depressed; however, the vehicle failed to respond. The contact also stated that the check engine warning light and the air bag warning light were illuminated. The vehicle was taken to the dealer to be diagnosed. The vehicle was not repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 9,000. The VIN was not available.

I rented a 2016 Ford Explorer from avis at the portland (me) airport (avis vehicle #40933351). On Friday, July 15th, the unit stalled as I pulled into an intersection. The accelerator was non-responsive and the car moved at a very reduced rate of speed. Several lights on the dashboard lit up - check engine, airbag, and a note came up to check the owner's manual. I was able to finish crossing the intersection at the slower speed and pull to the side of the road. I shut the car off and restarted it and it operated properly for a while. Later that night, I stopped at a stop light. When the light turned green, I made a left hand turn. Once again, the accelerator stopped working and the dashboard lit up with multiple warning lights. I pulled to the side of the road and called avis roadside assistance. The person on the line told me this was a common issue with Ford Explorers and that I had to turn the car off, step on the accelerator, then put my foot on the brake and restart the car to clear the fault but the check engine light would stay on. The check engine light stayed on but I was able to pull back onto the road at full speed. Approximately 1/4 mile down the road I stopped at a traffic light. Once again, I began to cross the intersection when the accelerator stopped working and the dashboard lit up. I pulled over and reset the car as I had done before and proceeded to drive away. A few hundred feet away, the accelerator stopped working again and the dashboard lit up. I was able to pull over, reset the car and drive away. This is an extremely dangerous condition that needs to be fixed immediately. The accelerator stops working without warning and the car only travels at a very slow speed that is not controlled by the accelerator. 3 out of 4 times it happened in the middle of an intersection. If there was oncoming traffic, I would have been hit.

Driving on I-10 about 1 mile before daphne, al, engine sputtered and vehicle began loosing speed. Pressing the gas pedal did nothing, check engine light came on, service manual light came on, and airbag light came on. Coasted to the side of the interstate, stuck between the white line of the lane edge and a guardrail with only inches to spare from traffic passing at 70 mph. All this with my wife in the front seat and our 2 daughters in the backseat who are 2 years old and 5 months old. Engine was running rough and would not increase rpms even when pressing the accelerator pedal. Shut engine off and on 6 times before it finally responded to accelerator pedal input. Was finally able to merge back on to the interstate and get to the daphne exit. We had to stay the night in a hotel in daphne while we waited for another vehicle to get us home to louisiana. This was a rental vehicle and had to be towed to the mobile airport so that we could get another vehicle from enterprise. A quick internet search revealed numerous complaints of the exact same issue but no evidence of any recall. Apparently the throttle body is faulty and most people report that the part is on back order. Ford knows about this problem and NHTSA should too but somehow nothing is being done. This incident left us on the side of the road, inches from being killed by passing motorists. How this is not under a recall or stop sale order is beyond me. Please initiate a recall and/or stop sale order on these vehicles before someone is killed or seriously injured.

This particular problem occurred three times over two days. The first time I was driving approximately 45mph on a city street when a wrench light and airbag light came on and the vehicle's throttle stopped responding. If I let off the break the vehicle would continue to move at approximately 5mph so I was able to get it off the roadway. I turned the vehicle off and back on and it seemed to be functioning normally with the check engine light illuminated. I was able to make it to my office where I left it parked until after lunch. When I cranked up the vehicle after lunch the check engine light was no longer on. After driving approximately ten more miles I attempted to make a left turn into a parking lot when the same thing happened and I was almost hit by an oncoming truck. After turning the vehicle off for a while I cranked it again and the check engine light was not illuminated. I made it home with no issue and the next morning I left home heading to the dealership to drop the vehicle off. As I was turning left on to a side street the vehicle again stalled and again I was almost struck by oncoming traffic. I turned the vehicle off and back on and after that was able to make it to the dealership without an issue. The diagnostic test indicated that the electronic throttle body was the issue. The dealership informed me that this was a widespread problem. The vehicle I was operating is an undercover police vehicle and only has 9,000 miles on it. Had I been responding to an emergency at a high speed I fear that either I or another motorist could have been seriously hurt or killed.

The contact owns a 2016 Ford Explorer. While driving 45 mph, the check engine light illuminated, the vehicle lost power, and stalled. The contact was able to restart the vehicle and coasted to the side of the road. The vehicle was towed to a dealer where it was diagnosed that there was an issue with the throttle body, which needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 52,000.

Driving at highway speed check engine light and "wrench" showing a powertrain problem occured while driving at 70mph. Was in the left lane of traffic and due to the continued lane expansions in around the area of travel could not pull off into the center median. Had to negotiate moving across 4 lanes of traffic with no acceleration during morning rush hour in a brand new 2016 Explorer with less than 7500 miles. Once I was able to get across the lanes of traffic the vehicle was undriveable. This appears to be a continued defect with Ford and the NHTSA needs to address it before someone gets into an accident and a fatality occurs.

I was driving in a parking lot when the wrench light came on, as well as the check engine light, and the car lost all accelerator function. I was able to coast only. I was driving straight when this occurred. Since I was already in a parking lot, I was able to coast into a parking spot. Luckily there was no safety threat, as it could have been much worse if I was on the freeway or city streets. The dealership reports this is a throttle problem and the part is on backorder until 5/30/16.