18 problems related to body have been reported for the 2007 Ford F-150. The most recently reported issues are listed below. Please also check out the statistics and reliability analysis of the 2007 Ford F-150 based on all problems reported for the 2007 F-150.
Frame has rotted away.
I’m wondering why there is no recall on the frames my truck has 96k and the frame is almost gone 2007 F-150.
Yesterday I discovered that the frame of my truck is completely rusted through in at least 2 places on the passenger side. I cannot confirm these are the only areas. The passenger side appears much worse than the driver side.
Frame, brake lines and all metal under carriage corroded to the point of being unsafe. Body only has minimal rust on rear corner pillars. Unsafe to operate.
I went to have my brakes replaced on my F-150 with 54,000 miles on the odometer and the mechanic told me the frame was completely rusted out and that he was able to put a screwdriver through it. He didn't want to install the brakes. I have owned this truck since new and it has (mostly) been garaged throughout. The body panels, interior , transmission, engine, etc. Are in excellent shape. It appears to be the same problem reported by many others, so I'm not sure why there hasn't been a Ford recall on this dangerous situation. It's obviously been going on for some time, but I never looked under the truck to see the extent of the rust, given that the body was in great shape (no rust).
The contact owns a 2007 Ford F-150. The contact stated that water drained onto the front passenger side floorboard when it rained. The dealer was not contacted. The manufacturer was made aware of the failure and referenced technical service bulletin number: 07-13-5. The contact was informed that the vehicle was not included in a recall. The vehicle was not diagnosed or repaired. The failure mileage was approximately 137,000.
This is regarding a 2007 Ford f150 supercrew. During the vehicles yearly inspection it was discovered that the frame of the vehicle under the cab is completely rusted out and cracked extensively. It is cracked beyond repair and no longer safe to drive. This vehicle is only 12 years old and should not be experiencing extensive premature rust in this way. There are alot of these trucks on the road and it's only a matter of time before someone gets hurt.
O/d off light , transmission fault on information display intermittent light and tone! truck would not start, pcm failure $3500 dollars in repair, at Ford dealer still not fixed!.
I bought this truck June 28 2010. On 2-11-14 I took it to Ford dealer because of frame rot and was told they could not cover the repair. I had it repaired at a welding shop. The truck frame is now so bad that it is unsafe and will not pass inspection. It has separated at factory weld. Obvious manufacturing defect.
Tl- the contact owns a 2007 Ford F-150. The contact stated that after grabbing the safety handle on the driver's side door the part detached from the vehicle. The vehicle was taken to the dealer where it was confirmed that the handle had detached and it needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 70,000. Kh.
2007 Ford F-150 XLT with 5. 4l triton v8,engine began shaking violently while at stop light, then hesitated consistently while accelerating 40-50mph, no warning lights or indicators on in truck. Ford dealership replaced coil I believe, just purchased the truck used and didn't get any documentation when they fixed it.
The contact owns a 2007 Ford F-150. While parked, the vehicle failed to start. The vehicle was taken to an independent mechanic who diagnosed that the fuel pump needed to be replaced. The vehicle was repaired; however, the technician stated that the fuel driver module was corroded and needed to be replaced. The manufacturer was notified of the failure. The failure mileage was 100,000. Ma 08/14/15.
I was driving down the road and I heard a loud popping noise so I pulled off on the side of the road and turned the truck off. I then saw smoke like the engine had overheated but in a matter of seconds flames ignited and I quickly got out of the vehicle and called 911. As I was speaking to the dispatcher there was a loud explosion and the whole front of my truck was engulfed in flames. By the time the fire department arrived and put out the fire my hood was totally burned up the engine is burned up and melted and the windshield and driver's side window blew out and the dash and front interior is burned and melted. I am lucky that I was able to get out in time because it happened so quickly. I am also glad my 10 month old son was not with me on this day.
The contact owns a 2007 Ford F-150. The contact stated that the side support handles used to lift oneself into the vehicle became fractured. The vehicle was taken to the dealer but was not repaired. The contact stated that it was the second occurrence of the failure. The failure mileage was 48,000.
I was stopping and about to park into a parking stall. As I was applying my brake, the vehicle suddenly accelerated. It jumped a curb, crossed a landscape island, took down shrubs, then stopped on the other side. It happened few other times, but not to this extend. Other times I thought I may have accidentally pressed on the gas pedal, and did not pay too much attention. One other time it happened, it was raining when I thought perhaps it was the rain that caused it.
The molding with built in handle broke while I was getting into my truck. I fell backward and caught myself on the truck door so that I would not fall onto the parking lot. The part number is 4l3z-1503599-aaa. I repaired the truck put in new molding.
Cab corner rust out rock pall rust out when I pay 38000 grand for a truck new off the lot now with 30000 miles should not be that much rust come to find out on the back of the cab corner there a gap where water leck in to the rocker and the water lays in there and rust out the bottom of the door and how hard would of been to run a bead of seam sealer for water could of got down in there.
The contact owns a 2007 Ford F-150. The contact was entering the vehicle and grabbed the pull up handle located on the driver's side front door. As the contact grabbed the handle, the handle detached from the vehicle. The vehicle was taken to the dealer and the manufacturer was made aware of the failure. The vehicle was not repaired. The failure mileage was 60,000 and the current mileage was 68,000.