Three problems related to manifold/header/muffler/tail pipe have been reported for the 2008 Ford F-150. The most recently reported issues are listed below. Please also check out the statistics and reliability analysis of the 2008 Ford F-150 based on all problems reported for the 2008 F-150.
Tl- the contact owns a 2008 Ford F-150. The contact stated that while operating the vehicle the odor of exhaust fumes were present inside the cabin of the vehicle. Also while idling the vehicle would rattle and shake. The vehicle was examined by an independent mechanic who discovered a crack in the exhaust manifold. The cause of the crack was not determined. The vehicle was not repaired. The local dealer joe machens Ford(807 southwest blvd, jefferson city mo). The manufacturer was not notified of the failure. The failure mileage was 100,000. Jft.
Bought my truck without knowing that it has a common is with the exhaust manifold leak. It is real bad where the fumes get in the cab of truck when it first starts up this issue has lead to other health issues for me.
I have a 2008 Ford F-150 king ranch with a 5. 4 l engine. Exhaust studs have snapped off causing a leak from the exhaust manifold and carbon monoxide fills the cab of this vehicle setting at idle. Ford has a problem with this engine for using a non conforming grade of stud. According to forums that I have researched showed that Ford has changed the studs. They are now using stainless steel studs. Is there a possibility of a recall on this vehicles engine for a repair to change all studs to stainless steel. I purchased this vehicle used and noticed the problem after the 30 day warranty had expired. Buyer beware! protect your family from this problem.