Other Fuel System Pump problems of the 2012 Ford F-250

Tl the contact owns a 2012 Ford F-250. The contact found metal shrapnel in the fuel system, which traveled to the engine. Multiple unknown warning indicators illuminated. The vehicle was towed to an independent mechanic where the battery was changed. The mechanic diagnosed that the fuel injectors and fuel pump needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and did not assist. The dealer was not contacted. The failure mileage was 188,180.

I got on the highway and was doing a turnaround when I accelerated to enter the highway lanes a warning light that said reduced engine power appeared on my dash. Approximately 200' later my truck died on the highway. My high pressure fuel pump went out and apparently disintegrated sending aluminum shavings throughout my entire fuel system. The fix is to replace the entire fuel system at a cost of $11,200. The Ford company is claiming the fuel was contaminated and caused the pump to rust and go out. I have never got a water in fuel warning light on my truck and have had all the required maintenance done on the truck. The insurance company had a lab do a sample of the fuel in my truck and the fuel met all the astm requirements.

The high pressure fuel pump failed. I have taken the truck to two different dealerships and they have said the same thing. They are saying that it is a fuel issue but the pump on the truck isnt equipped with the incorrect fuel pump for the diesel that is sold in the us. I have spent just about $2000. 00 just fighting the warranty company to fix the truck I drove for 10 days before failing. The truck has been in the shop longer than I have had it.

The contact owns a 2012 Ford F-250. The contact stated that while driving 25 mph, the vehicle stalled and the steering wheel became difficult to maneuver. There were no warning lights that illuminated on the instrument panel. The vehicle was merged to the side of the road where the contact noticed that diesel fluid was pouring out from under the hood. The vehicle was towed to the dealer. The technician diagnosed that the high pressure fuel pump needed to be replaced. The vehicle was repaired. The failure mileage was 21,799 and the current mileage was 22,000.