Two problems related to other fuel system pump have been reported for the 2015 Ford F-250. The most recently reported issues are listed below.
After driving approx 1 mile on surface street leaving work, a grinding noise was heard from fuel pump under vehicle under driver location. After 30 seconds check engine light illuminated and low fuel pressure message appeared in message area. Then reduced power appeared in message window. It happened so quickly that it left me stranded in the middle of the street with traffic on both sides until police came by and assisted. The truck was only able to idle for a minute until it died in the middle of the street. Truck was taken via tow truck to local Ford dealer. Once there diesel tech cleared codes and stated they could not find anything wrong.
The truck seemed to be running out of gas, surged, sputter, surge sputtered then quit running. I had 1/2 a tank. Had to cost the truck a crossed speeding traffic lanes and came to a stop on an over pass. Had the truck towed to the dealer. The dealer findings were a problem with the fuel pump and controller. The dealer stated when they enter the check engine code (p0627) into their wan, they shortly had a call from Ford engineering wanting the parts returned to them and with instructions not to replace them with the same part number. It seems this was a known issue and had been flagged in their network by Ford engineering. It seems this issue was unknown by the dealership. It bothers me greatly that this issue is known by Ford engineering but the dealers are selling new trucks with this known defect. The new truck has sat at the dealer for three weeks because the controller part is not available.