Three problems related to underhood wiring have been reported for the 2004 Ford F-350. The most recently reported issues are listed below.
Update on complaint #10172522. . . Received truck back from dealer Nov. 9. They replaced the egr valve(under warranty). That evening truck "surged" twice. Friday Nov. 10 truck died, restarted then almost died again. Ran fine after this. Took back to dealer Nov. 10 this is the fourth visit to the dealer.
2004 F-350 super duty with 6. 0l bought new in 2004. Summer of 2006 experanced "surge" while driving on interstate in cruse control. Later same problem at 30 mph. Problem was worst in September, truck surging and died at idle. I replaced cam sensor, no fix. Took truck to dealer. Loaded new program and changed sensor on turbo and changed transmission filters $200. 00. Morning of oct 19 ,leaving for atlanta with familt and camper same "surge". In atlanta oct 20 in trafic truck surged and almost hit a car from behind. Monday oct 23, truck surging badly , tried to die at two red lights. Later no problem. Took to dealer again, found no problem. They wanted to change fuel filters ($120. 00). Nov 02, son drove truck school, truck surged twice at red light, tried to push him through lntersection. Dealed has no fix. They have truck now (Nov 03). They offered to sell my a new one for $15,000. 00.
Ford F-350 diesel-2004 car shut down in the passing lane on PA turnpike. Towed to Ford. . . No insulation on wiring harness, shorted out the truck. The truck stopped dead in the road. . Now the Ford dealer fixed it by putting insulation over it to get me back on the road. It had been in the shop the week before, and the week before that because I complained of losing power on the road when I travel. I don't want to have a fire with my family!.