Table 1 shows one common diesel fuel system related problems of the 2011 Ford F-350.
| Problem Category | Number of Problems |
|---|---|
| Diesel Fuel System problems |
The contact owns a 2011 Ford F-350. The contact stated while reversing, the vehicle failed to accelerate as intended while depressing the accelerator pedal. The contact stated that the vehicle stalled and failed to restart. There was no warning light illuminated. The contact stated that an independent mechanic arrived at the residence however, the vehicle failed to restart. The vehicle was towed to an independent mechanic. The contact was informed that the high-pressure fuel pump had failed, and the fuel system needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure but denied assistance in covering the cost of the repair. The failure mileage was approximately 200,000.
The contact owns a 2011 Ford F-350. The contact stated that while driving approximately 30 mph, the vehicle lost automotive power and stalled. During the failure, diesel fuel and oil spilled from the engine. The vehicle was towed to the local mechanic who diagnosed that the strap that secured the fuel injectors had failed, causing the fuel injectors to eject from the engine. The contact was advised that the fuel injector straps, fuel injectors, and several fuel hoses needed to be replaced. The vehicle was not yet repaired. The manufacturer and local dealer were notified of the failure, but no assistance was offered. The failure mileage was 40,000.
The contact owns a 2011 Ford F-350 sd. The contact stated while driving 50 mph, the vehicle jerked and lost motive power. The contact was able to pull over to the side of the road. The check engine warning light was illuminated. The vehicle was restarted; however, the vehicle drove at a reduced speed. The vehicle was taken to an independent mechanic, where it was diagnosed and determined that metal shavings were found in the fuel filter. The vehicle was not repaired. The contact stated that the failure persisted. The manufacturer was not notified of the failure. The failure mileage was approximately 77,000.