Steering Tie Rod Assembly problems of the 2019 Ford F-350

The contact owns a 2019 Ford F-350. The contact stated that the vehicle experienced the death wobble. The contact stated that when the vehicle rode over a pothole, the steering wheel shook violently. The contact stated after approximately five to ten second the shaking to stopped. No warning light was illuminated. The contact stated that the vehicle was taken to burns Ford (2001 charlotte hwy, lancaster, SC 29720) three times. The steering damper, the drag link and track bar ball joint, the passenger's side upper tie rod were replaced. The contact stated that the repairs failed to fix the failure. The failure persisted. The manufacturer was not made aware of the failure. The failure mileage was approximately 70,000.

My 2019 Ford F-350 has approximately 16,300 miles on it. On Friday, November 8, 2019, I was driving at highway speed (approximately 65 mph) westbound on interstate 10 near san antonio, TX around mile marker 588 shortly after noon. I was in the left lane. I hit a small, but relatively deep pothole in my lane, which caused a jolt to the vehicle. What followed next is difficult to describe as I have never experienced anything like it in over 40 years of driving. The front end of the vehicle started to shake and wobble violently. I initially thought both of the front steer tires had experienced a blowout simultaneously as the shaking was occurring on both front tires and the front suspension. The vehicle was very difficult to control. I was able to decelerate and move to the right shoulder. At some point during my deceleration, perhaps around 25 mph, I was able to regain control of the vehicle and the shaking stopped. I exited and inspected the vehicle, but could see no damage to either tire, nor any indication of damage to the tie rods, shocks or other components of the front suspension. I was able to resume driving and later conducted a more thorough inspection, again finding no apparent damage or cause for the violent shaking and wobbling I had experienced. I am terrified that this will occur again. In different circumstances, this could easily result in loss of control of the vehicle, with very bad consequences. I occasionally pull fifth wheel and goose neck trailers with this vehicle, which is why I purchased it. If this occurred while pulling a load, the consequences could be terrible.