Wiring Problems of Ford Five Hundred

The contact owns a 2007 Ford Five Hundred. The contact stated that the side mirror on the front passenger side door caught fire. The dealer stated that there was a short in the wiring harness. The vehicle was not repaired and the manufacturer was not notified. The failure mileage was 82,172.

See all problems of the 2007 Ford Five Hundred 🔎.

The contact owns a 2005 Ford Five Hundred. The contact stated the vehicle would intermittently and abnormally accelerate without driver intent. The failure would occur whether the vehicle was in drive or reverse. The vehicle was taken to a local repair shop where the mechanic was unable to duplicate the failure. The vehicle was scheduled for further diagnostic testing by the dealer. The failure mileage was 106,000 and the current mileage was 108,000. Updated 08/24/lj the consumer stated the vehicle randomly accelerates at a rate of 65 mph when her foot is not on the gas pedal. The vehicle also has wiring problems that leads to the headlights causing them to fail. The wires overheat and sometimes flickers. The casing melt as well and then the lights begin to smoke. Updated 08/25/10.

See all problems of the 2005 Ford Five Hundred 🔎.

Low beam headlamp socket on the drivers side failed. One of the socket contacts showed evidence of a catastrophic electrical failure - looks like severe arcing, burned plastic, broken socket shell and badly burned pin in the lamp. The lamp itself is still o. K. , except for the badly burned pin. About a week and a half later the same thing happened to the low beam lamp on the passenger side. Same damage to the same pin in the socket. That lamp is also o. K. Except for the burned pin. This would appear to be a problem with the sockets/vehicle wiring, not the lamps. These lamps are mounted quite high and are reasonably well protected so it is unlikely that this is a moisture problem. The cost of the replacement socket from Ford is simply outrageous! dealer says this is the first case they've seen of this happening - but I heard the same thing when I had problems with the rear brakes and I now know that certainly wasn't true! has anyone else had this problem?.

See all problems of the 2006 Ford Five Hundred 🔎.

The electrical system through out the car is being heard in the speakers. If the seats, window, etc. , etc. Are touched you can hear them through the back end with a loud roaring noise. It is so loud that you can not keep the radio on. It only reacts when it is extremely hot, extremely cold or after the car has been washed or it rains. We have taken this to the dealer where the amp, radio, cd player and speakers have all been replaced 3 times. They have even eliminated water leak which only leaves wiring issues in which they refuse to replace. Our fear is that it could cause fire. We have arbitrated and contacted corporate and they refuse to do anything about it. We even took this to another Ford dealer in which they told us after showing them all the work orders that they will not get involved since it is a pre-existing issue that another dealer has tried to resolve many, many times. Just be cautious and place your vehicle inside away from these conditions so it doesn't act up and cause more issues.