Other Fuel System Tank Assembly problems of the 2014 Ford Fusion

When fueling the tank vehicle will not stay running. Engine starts and then dies. This goes on up to five minutes then engine stays running with no check engine light on. Check codes there is p1450 stored. Other times it happens after driving and turning engine off and then re starting a few minutes later, sometimes the engine stutters and dies after driving which can be in a parking lot or make to the highway stop at a stop lights which gets really scary when other traffic is around. I look up my VIN for recalls it shows none. It starting happening a while back just once in a while accurrence, now everytime I fill up.

Takata recall: the car is stalling while I am in drive, with speeds up to 70 mph. It also will not start after I have put gas in the tank. I have to step on the gas to gwt it to start. The car is also shaking back and forth while in park just trying to stay started. Then it will die. Everytime I come to a stoplight or a stop sign I go through this and have great difficulty starting it back up continuously.

Gas tank makes a loud tapping noise at low speeds when the gas tank is over 3/4 full.

Tl the contact owns a 2014 Ford Fusion. While the vehicle was at a stop, the contact heard an abnormal noise coming from the fuel tank. The vehicle was taken to an independent mechanic who diagnosed the vehicle and stated that the purge valve failed. The vehicle was not repaired. The manufacturer and dealer were not notified of the failure. The failure mileage was approximately 75,000.

Has rattle under passenger floor when fuel tank is 3/4 to full in park or in gear at complete stop or just creeping below 5 mph and have read online about the baffles breaking in the fuel tank causing this issue also read it causes air in fuel line which could be a safety issue while traveling down highway if engine cuts out due to this issue,, also drivers door doesn't always latch 100 % sometimes have to open and close door several times to shut completely and has started doing this since October of 2018 also transmission shifts funny when cold going from park to reverse has very harsh engagement and 3rd shifts very firm when going in.

The contact owns a 2014 Ford Fusion. While driving approximately 70 mph, the check engine indicator illuminated. The vehicle was driven to the contact's residence where a scan tool was used to diagnose the engine, which generated a p1450 code. The code was reset and the failure recurred. The vehicle was not taken to a dealer. The vehicle was not repaired. In addition, after fueling the fuel tank and attempting to drive, the vehicle hesitated and stalled. The contact was able to restart the vehicle, but the failure recurred each time fuel was placed in the vehicle. The contact called the Ford murfreesboro dealer in tennessee where an appointment was scheduled for diagnostic testing. The VIN was not included in NHTSA campaign number: 15v793000 (fuel system, gasoline). The manufacturer was not made aware of the failure. The approximate failure mileage was 100,000.

Heard a loud noise coming from near the gas tank, sounds like a googling or funny noise check engine light comes on and the car sputters and cuts off. All the noise was being made while driving it didn't stop until I put the car in park.

Gurgling in gas tank area after gas fill up can be heard in passenger compartment until tank gas level goes down between 3/4 and full. Only occurs when gas tank is full or very near full.

Wether the car is cold or warm, everytime I drive, I get a hardshift between 2nd and 3rd gear. Also when I make a stop and try to accelerate, the car jerks from on the 1st gear. When I'm going on a downhill and let go of the gas pedal and slowly start braking, the would go from 2,000 rpm to 5,000 rpm while I have my foot on the brake. When I go to any gas station I can't leave the pump on auto because it would stop pumping, so I have to do it manually, in order to get a full tank.

Bought a new 2014 Ford Fusion se ego boost in July of 2014. When fuel tank is full, there is a loud and distinct rattling noise originating from the back of the car which appears to be coming from the fuel tank. Initial inspection by Ford failed to determine the nature of the problem as they were not able to replicate the noise. Driving the car for several weeks led me to determine that the noise was present only when the fuel tank was full. I brought the car back to Ford twice, both times with a full tank of gas. The service manager told me the noise is "normal" but there is nothing normal about it. I've escalated my concerns to Ford's corporate office and the woman I spoke to told me that the noise is inherent in the design and not a safety problem, I told her that anytime a fuel tank is vibrating and hitting either the exhaust or the under body of the car it is a safety concern. She told me that her tech have informed her that the noise is coming from bad baffles in the tank, I told her that who ever said that thinks that I am stupid and that I can't tell the difference between a rattle and a baffle problem. She repeated it not a safety concern. I told her that it may not seem that way now, but years down the road when the fuel starts to leak from years of rubbing it will be because at that time a fire or explosion will happen. At this point Ford refuses to do anything to fix this issue.

After fill up slow in parking lot hear what sounds like a bad wheel bearing from r rear. Checked out other complaints found Ford will replace some more expensive model fuel tanks not mine. Was told to live with it . There is a service bulletin from Ford same year as mine . I have a base model so I don't qualify . It's true it's a brand new car! $23,000 it cost me .

When driving at slow speeds, making parking manuevers, or just stting still there are noises coming from the gas tank area of my vehicle. They sound like rattling, gurgling, vibrating, or percolating sounds. I have taken my vehicle to two different Ford dealers in my area and neither one can/will tell me what these noises are, all they say is that it could be a few different things and that it is a normal operating feature of this model vehicle. Frankly I dont believe that as I have never heard this noise from any other car I have owned. Furthermore if the dealers themselves cant tell me why my car is making this noise than how can they say its normal.

Bought a new 2014 Ford Fusion in October. When fuel tank is full, there is a loud and distinct noise originating from the back of the car which appears to be coming from the fuel tank. Initial inspection by Ford failed to determine the nature of the problem as they were not able to replicate the noise. Driving the car for several weeks led me to determine that the noise was present only when the fuel tank was at least 5/8s full. I brought the car back to Ford twice, both times with a full tank of gas. Two different service managers tell me the noise is "normal" but there is nothing normal about it. I've escalated my concerns to Ford's corporate offices on at least 3 occasions and they have never once returned my calls or responded to my written inquiries. Noises from the fuel tank are, naturally concerning and disconcerting. My friends just bought the same car and they have not experienced the same noise so I believe that they know a problem exists and corrected it, but only prospectively.