14 problems related to car stall have been reported for the 2016 Ford Fusion. The most recently reported issues are listed below. Please also check out the statistics and reliability analysis of the 2016 Ford Fusion based on all problems reported for the 2016 Fusion.
Car wouldn't accelerate. Would stall after pumping gas would overheat when idling. Fans were not turning on canister purge valve stuck open causing the fuel tank and oxygen sensor to fail. . Runs rough.
Tl the contact owns a 2016 Ford Fusion. The contact stated that while operating the vehicle, the message engine malfunction displayed on the instrument panel. The vehicle loss motive power and stalled. The cause of the failure was not determined. The local dealer roy o�brean Ford located at 22201 east nine mile rd, st. Clair shores, mi 48080 and the manufacturer were notified of the failure. The failure mileage was 87,000. The VIN was available.
I drive a 2016 Ford Fusion se awd with the 2. 0l ecoboost/gtdi motor. I was at a gas station refueling my vehicle, with the 87 octane fuel the oem calls for on the vehicle. I was about 1/4 tank before refueling and I filled my tank until full. Upon starting my car, I always turn the key right before ignition and wait for the fuel pumps to draw gas to the motor, then start it. Started seemingly fine, however, while I was resetting my mileage trip counters, I noticed, and felt my rpm's drop down into the 300-400 area and my motor shook my car. I kind of was surprised as my car had never done this, so I figured maybe it was just an engine stutter. But then upon waiting a few more seconds, it did it again, 4 more times and felt like my motor was ready to stall out. I was still parked/stationary beside a gas pump so I put the car in drive to go park myself in an actual spot so I wasn't in the way of other vehicles. I kept my car running in park to see if the rpm's would drop again, but upon waiting five minutes, it did not. The rpm's were a bit wobbly though on the tachometer but did not significantly drop. No lights on the dash came on. I wasn't taking any chances, I immediately called the dealership to have my car serviced. Turns out, my canister purge valve was stuck in the open position. Sounds all too familiar, accounting that Ford issued a recall for the exact same issue with many Ford focus models, with the exact same motor. This is a serious issue that can result in crash/injury or even death. No light came on for me and I only caught it because I was superstitious enough to bring it in regardless. This should be investigated, it is literally the same issue and I'm baffled as to how his hasn't been made into a recall by now. I know I'm not the only one who has faced this issue, so please, I ask for this to be investigated and deemed a recall as it's a big issue.
2016 Ford Fusion ES stalls out during driving does not matter if vehicle is stationary or in motion stalls have occurred in parking lots highways and roads this problem occurs at random times you must stop vehicle put in park and restart.
Tl the contact owns a 2016 Ford Fusion. While driving various speeds, the vehicle suddenly stalled. The vehicle was taken to mall of georgia Ford (4525 nelson brogdon blvd hwy 20, buford, GA) to be diagnosed, but the cause of the failure could not be determined. The manufacturer was not notified of the failure. The failure mileage was 42,500.
When I put gas in the car, it is very hard to start. I have to pump the gas and then rev the engine to get it to stay on. If I leave it in park, without reving the engine, it will stall out. Once I get it into drive and start moving, the problem subsides. The only other time I notice it, is if I am idling on a hill. At that point, it will stall without constant feathering of the gas pedal. This seems to be consistent with the current recall on some of the 2016 Ford Fusions, but my VIN doesnt appear on the recall.
Tl- the contact owns a 2016 Ford Fusion. The contact stated that the vehicle had stalled several times with no warning. In addition, the vehicle had been extremely difficult to start after refueling. There was an engine warning light that had flashed intermittently as the failure progressed. The vehicle was not inspected and diagnosed by a dealer yet but hennessy Ford Lincoln atlanta, 5675 peachtree industrial blvd, atlanta, GA 30341, 1-(770) 621-0200 was notified of the failure. The vehicle was not included in an unknown electrical system recall campaign from the manufacturer however the vehicle exhibited the same failure as the recall. The manufacturer had issued 25 TSB on electrical and 16 TSB on the engine and engine cooling however there was no recall open for the vehicle. The manufacturer was notified of the failure and provided no assistance other than the contact having the dealer diagnose and repair the vehicle. The VIN was not available. The approximate failure mileage was not available. Dyd.
Tl- the contact owns a 2016 Ford Fusion. The contact stated that while driving approximately 40 mph the vehicle suddenly stalled. After pulling over to the side of the road the engine was restarted and the vehicle operated as normal. The vehicle had also stalled on several occasions while idling. The cause of the failures were not determined. The local dealer and the manufacturer were not notified of the failures. The VIN was not available. The failure mileage was 45,000. Jft.
The contact owns a 2016 Ford Fusion. The contact stated that while driving at 80 mph, the vehicle stalled without warning. The contact stated that the vehicle stalled abruptly and began to shake. The contact noticed that the "wrench" as well as the engine warning lights illuminated immediately afterward. The contact turned off the vehicle and restarted it, but the vehicle would not accelerate. The vehicle was towed to auto nation Ford of katy, texas where it was determined that the throttle needed to be replaced. The vehicle was repaired. The manufacturer was made aware of the failure and stated that the customer service program bulletin #: 16v32, had expired on the vehicle September 30, 2017 regarding the throttle body failure. The failure mileage was approximately 7,000.
The contact owns a 2016 Ford Fusion. While driving 40 mph, the check engine and wrench icon indicators illuminated. Also, the vehicle stalled without warning. The contact was able to restart the vehicle and drive away. Park Ford of tallmadge, ohio stated that the throttle body needed to be replaced. Autonation Ford westlake in westlake, ohio repaired the vehicle. The manufacturer was made aware of the issue and stated that the vehicle did not qualify for a buyback. The VIN was invalid. The failure mileage was 20,000.
Driving 25 mph down side street, when car lost power and almost stalled. Engine check light and wrench light went on, and engine cut out. Restarted car and was able to pull off of road. Waited a few minutes and car restarted, luckily was only 1/2 mile from home. Car dies again in driveway. Called Ford to have them pick it up, which they did. Service thought it was throttle body. Picked up car next day and it was throttle body, which they replaced. Ford service knew of problem, but I had received no notification of problem. This is a major safety problem. I am luck I wasn't going 70 on freeway.
The contact owns a 2016 Ford Fusion. While driving approximately 60 mph, the accelerator pedal was depressed and the vehicle failed to accelerate. The check engine and air bag warning indicators illuminated continuously. The vehicle came to a complete stop, shook, and stalled. The vehicle was able to restart. The dealer could not duplicate the failure. The manufacturer was not made aware of the failure. The failure mileage was approximately 9,700.
The contact owns a 2016 Ford Fusion. While driving approximately 65 mph, the vehicle decelerated and stalled. The wrench warning indicator illuminated and the vehicle shook violently. The contact had to coast the vehicle to the shoulder. The vehicle was towed to the dealer where it was diagnosed that the throttle body assembly failed and needed replacement. The vehicle was repaired. The manufacturer was notified of the failure. The approximate failure mileage was 10,900.
Tl- the contact owns a 2016 Ford Fusion se. The contact stated that while driving at low speeds or stationed , the vehicle shuttered and stalled with no warning. The vehicle was taken to john bleakley Ford inc 870 thornton rd, lithia springs, GA 30122 (770) 941-9000 where the engine was replaced. The contact mentioned that the failure reoccurred after the repair. The manufacturer was not notified of the failure. The VIN was not available. The failure mileage was approximately 63,000. Dr.