Three problems related to warning light on have been reported for the 2016 Ford Fusion. The most recently reported issues are listed below. Please also check out the statistics and reliability analysis of the 2016 Ford Fusion based on all problems reported for the 2016 Fusion.
A few weeks after having recealls performed for the steering and airbag issues, I was driving on the freeway and got a warning light(attached) that said "steering fault service now". The steering bacame slightly sticky but still drivable. After reacbing my destination and restarting my car, I then received the same fault light as well as traction control, and airbag lights. I have had zero issues with this vehicle as long as I've owned it prior to it being at the dealer for the recalls. The steering was now almosy inopperable and required alot of strength to make any turn left or right. While luckily the steering got very bad on side streets, this could have resulted in some serious injury or problems if it happened on the highway I feel. This vehicle is just only 4 years old and I have a hard time believing that the steering mechanism should be faulty already. I unfortunately do not have warranty on this part of the vehicle so I am now left with a $2500 bill to repair a sealed rack and pinion assembly that doesn't (to my knowledge) require any maintenace. Hopefully there are enough of this issues to warrant an investigation and possible recall. Thank you,.
The air bag warning light will come on, will stay on until you cut the car off, but then it may not come back on next time. It's inconsistent. Sometimes it stays on while the car is running, sometimes it goes off a few seconds after cranking like it is supposed to do.
Abs lights, traction control lights, throttle body control lights, air bag lights, emergency break lights, rear right break lights all come on my dash, it is at random times, first starting the car up, driving it for 2 minutes or even up to 10-12 minutes. Speed, weather or making a turn or just going straight does not matter. Warning lights can go off every day multiple times or as lttle as once a week. You can feel the streeting get very tight, its hard to even make a turn which is not very safe. Had my vehilce in the shop for 25 days straight. Was told the issues were fixed and withint 7 hours of picking my car up all the same lights came on.