Door Problems of Ford Fusion - part 1

The contact owns a 2016 Ford Fusion. The contact stated that while driving at an undisclosed speed, he heard an abnormal slushing sound coming from the dashboard and doors. Additionally, after adding coolant, the coolant level was low again two days later. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 247,700.

See all problems of the 2016 Ford Fusion 🔎.

The contact owns a 2011 Ford Fusion. The contact stated that the driver's side door handle had fractured. The contact was unable to open the door from the inside. There was no warning light illuminated. The vehicle was taken to the local dealer where it was diagnosed with a fractured spring. The contact was informed that the button and door handle needed to be replaced. The vehicle was repaired; however, the failure recurred. The manufacturer was notified of the failure and referred the contact to NHTSA. The approximate failure mileage was 60,000.

See all problems of the 2011 Ford Fusion 🔎.

Tl the contact owns a 2014 Ford Fusion. The contact stated that the front passenger door failed to close and the door ajar warning indicator illuminated. The vehicle was not diagnosed or repaired. The manufacturer was contacted and provided case number: cas24056046. The dealer was not contacted. The failure mileage was 102,000.

See all problems of the 2014 Ford Fusion 🔎.

Tl the contact owns a 2014 Ford Fusion. While driving approximately 45 mph, the front passenger door opened without warning. The contact called jorgensen Ford sales at 833-894-4613 (located at 8333 michigan Ave, detroit, mi 48210) and was informed that the vehicle was not included in a recall. Two days later, while driving at an unknown speed, the rear passenger door opened. The manufacturer was made aware of the failures and stated that there was no recall; however, the contact was informed to take the vehicle to a dealer for evaluation. The vehicle was not repaired. The failure mileage was approximately 77,800.

The contact owns a 2014 Ford Fusion. The contact stated that the rear driver's door failed to remain closed. The contact called barber Ford (located at 640 e 8th st, holland, mi 49423, (616) 396-2361) and was informed that the VIN was not included in a recall. The contact also called borgman Ford Mazda (located at 3150 28th st sw, grandville, mi 49418, (616) 534-7651) and was informed that the VIN was a salvage title and was not eligible for the repair. The vehicle was not taken to a dealer and was not repaired. The manufacturer was notified of the failure and referred the contact to NHTSA. The approximate failure mileage was 80,000.

Tl the contact owns a 2010 Ford Fusion. The contact stated that the driver's door failed to open and close properly and could not be opened from inside the vehicle. The vehicle was not diagnosed or repaired. The vehicle was not included in NHTSA campaign numbers: 17v210000 (latches/locks/linkages) and 15v246000 (latches/locks/linkages); however, the vehicle exhibited the same failure as the recall campaigns. The dealer and manufacturer were not contacted. The approximate failure mileage was 100,000.

See all problems of the 2010 Ford Fusion 🔎.

Tl the contact owns a 2011 Ford Fusion. The contact stated that the interior door handle failed to open the driver's side door. An independent mechanic repaired the door handle. The manufacturer and dealer were not contacted. The failure mileage was 96,000.

Tl the contact owns a 2013 Ford Fusion. The contact stated that the front and rear passenger doors would not open from outside of the vehicle. There were no warning indicators illuminated. The vehicle was included in NHTSA campaign numbers: 15v246000 (latches/locks/linkages) and 17v209000 (engine and engine cooling). The dealer was not contacted; however, the recall notice instructed owners to schedule an appointment. The vehicle was not diagnosed or repaired. The manufacturer was not notified. The failure mileage was unknown.

See all problems of the 2013 Ford Fusion 🔎.

Tl the contact owns a 2011 Ford Fusion. The contact stated that the driver's side door failed to open from inside the vehicle. The vehicle was not diagnosed or repaired by an independent mechanic or a dealer. The manufacturer was notified of the failure. The failure mileage was not available.

Tl the contact owns a 2012 Ford Fusion. The contact stated that the driver's side front door failed to open from inside of the vehicle. The contact called mike bass Ford inc (5050 detroit rd, sheffield, OH 44035, (440) 934-3673), and the dealer was informed of the failure. The contact was informed to schedule an appointment to have the vehicle diagnosed. The contact stated that the failure occurred before and was taken to the same dealer, where the vehicle was repaired. The manufacturer was made aware of the failure and informed the contact that the vehicle was out of warranty. The vehicle was not repaired. The approximate failure mileage was 56,000.

See all problems of the 2012 Ford Fusion 🔎.

~tl the contact owns a 2013 Ford Fusion. While driving approximately 50 mph, the rear passenger side door opened without warning. The contact pulled the vehicle over to the side of the road and attempted to close the door with string. The vehicle was driven to the contact's residence. The contact also stated that the front door on the passenger side experienced the same failure. The vehicle was repaired at vicksburg Ford/Buick in vicksburg, mississippi (866-531-3936). The failure recurred, but the vehicle was not repaired again. The manufacturer was notified of the failure. The approximate failure mileage was 169,000.

The contact owns a 2011 Ford Fusion. While the vehicle was stationary, the driver's door latch fractured and the passenger door would not open when prompted. Coggin Ford jacksonville in jacksonville, florida was made aware of the failure and requested that the vehicle be brought in for diagnostic testing. The manufacturer was not made aware of the failure. The failure mileage was 58,000.

Tl the contact owns a 2011 Ford Fusion. The contact stated that the driver side door did not open from inside the vehicle. There were no warning indicators illuminated before or after the failure. The vehicle was taken to bob rohrman schaumburg Ford 450 (815 e golf rd, schaumburg, IL), but was not diagnosed or repaired. The manufacturer was notified of the failure. The VIN was unknown. The approximate failure mileage was 24,825.

The contact owns a 2012 Ford Fusion. The contact stated that the door handle became jammed when attempting to open the door. The contact had to pull the open lever and pull the door handle to open the door. Tamiami Ford (1471 airport pulling rd n, naples, FL) diagnosed that the vehicle needed a new door handle. The manufacturer was not notified of the failure. The failure mileage was approximately 90,000. The VIN was not provided.

The contact owns a 2012 Ford Fusion. The contact stated that the driver's side door failed to close and lock. The contact held the door and drove the vehicle to an independent mechanic (swann's tire pros and auto service, located at 338 s church st, ripley, wv 25271; (304) 372-5707) where they repaired the driver's side door to close; however, it still failed to lock. The vehicle was taken to the dealer (I-77 Ford, located at 3315 charleston rd, ripley, wv 25271; (304) 372-3673) where it was diagnosed that the driver's side door handle and door lock needed to be replaced. The vehicle was not repaired. The manufacturer was contacted at 800-392-3673 and provided case number: cas-13050159. The approximate failure mileage was 45,559.

The contact owns a 2010 Ford Fusion. The contact stated that the front driver side interior door handle did not work when he attempted to open the door. The contact stated that the outside door handle worked normally. The vehicle was driven to bloomington Lincoln (1001 clover drive bloomington, minnesota 55420) where it was diagnosed that the interior door handle fractured and needed replacement. The vehicle was repaired. The manufacturer was not notified. The approximate failure mileage was 87,000.

The contact owns a 2009 Ford Fusion. While the vehicle was parked, the contact attempted to exit the vehicle, but the driver's side interior door handle fractured. The contact had to roll down the window to open the door from the outside. The vehicle was taken to a dealer for diagnostic testing, but the results were unknown. The door handle was replaced. The manufacturer was not made aware of the failure. The failure mileage was 89,500.

See all problems of the 2009 Ford Fusion 🔎.

The contact owns a 2012 Ford Fusion. The contact stated that the front driver side door handle malfunctioned and the driver was unable to open the door to exit the vehicle. The cause of the failure was not diagnosed. The vehicle was not repaired. The manufacturer was notified of the failure. The VIN was invalid. The failure mileage was 44,800.

The contact owns a 2012 Ford Fusion. The contact stated that the driver's door was unable to open from inside the vehicle. In order to open the door, the contact had to reach out the window and use the exterior door handle. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 55,000.

The contact owns a 2012 Ford Fusion. The contact stated that the front driver's side door handle fractured. The contact stated that the door handle fractured and was replaced twice previously. The vehicle was not diagnosed or repaired. The contact stated that the vehicle was scheduled to be inspected by an independent mechanic. The dealer was not contacted. The manufacturer was informed of the failure. The approximate failure mileage was 93,000.

The contact owns a 2010 Ford Fusion. When the contact was exiting the vehicle, the door handle was pulled and an abnormal cracking noise was heard. The contact stated that the door failed to latch. As a result, the driver had to hold the door closed while driving. The vehicle was taken to the dealer where it was diagnosed that the front driver's side door handle fractured and needed to be replaced. The vehicle was repaired. The manufacturer was made aware of the failure. The failure mileage was 78,000.

The contact owns a 2013 Ford Fusion. The contact stated that the rear doors were re-opening involuntarily and the door ajar warning indicator illuminated on the instrument panel. The manufacturer was notified. The vehicle was not repaired. The failure recurred on several occasions. The failure mileage was 80,000.

The contact owns a 2006 Ford Fusion. When the contact attempted to exit the vehicle, the front driver side door handle failed to operate. As a result, the contact had to roll the window down to exit the vehicle. The vehicle was taken to a dealer where it was diagnosed that the driver side door handle needed to be replaced. The vehicle was repaired, but the failure recurred. The manufacturer was made aware of the failure. The failure mileage was 233,000.

See all problems of the 2006 Ford Fusion 🔎.

The contact owns a 2010 Ford Fusion. The contact stated that the interior driver side door handle fractured and was difficult to open in case of an emergency. The vehicle was not diagnosed or repaired. The manufacturer was not notified. The failure mileage was 80,000.

The contact owns a 2012 Ford Fusion. While the vehicle was stationary, the passenger door handle fractured. The vehicle was not repaired. The manufacturer was made aware of the issue. The failure mileage was 42,000.

Takata recall. The contact owns a 2006 Ford Fusion. The contact stated that the passenger side air bag warning indicator illuminated. In addition, the interior driver side door handle fractured. The contact received notification of NHTSA campaign number: 16v384000 (air bags); however, the parts to do the repair were unavailable. The manufacturer exceeded a reasonable amount of time for the recall repair. The manufacturer was notified of the issue. The failure mileage was approximately 48,000. VIN tool confirms parts not available.

The contact owns a 2010 Ford Fusion. When the down button was depressed on the front driver's side window, the window failed to roll down. The contact also stated that the front driver's side door failed to open from the inside. The contact had to exit the vehicle from the front passenger side door. The vehicle was taken to a dealer where it was not diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 99,000. The VIN was unavailable.

Tl the contact owns a 2011 Ford Fusion. The contact stated that the interior driver's side door handle fractured twice in three years. The door handle was repaired in 2016 for the same failure. The contact had to maneuver the door lock or reach outside the vehicle to open the door from the outside. Kenny ross Ford (104 black hill rd, irwin, PA 15642, (724) 864-3601) was expected to repair the vehicle on may 7, 2019. The manufacturer was not contacted. The failure mileage was 38,000.

The contact owns a 2010 Ford Fusion. After the vehicle was driven and parked, the contact attempted to exit and the driver side door would not open from the inside. The contact did not take the vehicle to the dealer or an independent mechanic for diagnostic testing. The manufacturer was notified of the failure. The vehicle was not repaired. The VIN was unknown. The approximate failure mileage was 60,000.

The contact owns a 2012 Ford Fusion. While driving 65 mph, the front passenger side door became ajar. The contact was able to close the door; however, it failed to lock properly. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The approximate failure mileage was 80,000.

The contact owns a 2008 Ford Fusion. When attempting to exit the vehicle, the door handle fractured. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The VIN and failure mileage were unknown.

See all problems of the 2008 Ford Fusion 🔎.

The contact owns a 2010 Ford Fusion. The contact stated that the driver side door did not open from inside the vehicle. The vehicle was taken to a dealer where it was diagnosed that the inside lining failed and needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 100,000.

The contact owns a 2012 Ford Fusion. The contact stated that the front driver, passenger, and rear passenger interior door handles were loose and failed to unlatch the door. The vehicle was taken to the dealer where it was diagnosed as a wear and tear item and not part of NHTSA campaign number: 15v246000 (latches/locks/linkages). The vehicle was not repaired. The manufacturer was notified. The failure mileage was 55,000.

The contact owns a 2013 Ford Fusion. While driving 25 mph, the front driver side door opened after the door ajar warning indicator illuminated. The failure recurred on one other occasion. The vehicle was taken to a dealer where it was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was 58,000.

The contact owns a 2012 Ford Fusion. The contact stated that the front driver side interior door handle failed to open the door properly. The contact had to roll down the window and open the door from the outside. The failure recurred multiple times. The technician stated that the door latch was potentially faulty and needed to be replaced. The vehicle had not been repaired. The manufacturer was not notified of the failure. The VIN was not included in NHTSA campaign number: 15v2460009 (latches/locks/linkages). The approximate failure mileage was 50,000.