Five problems related to engine clicking and tapping noises have been reported for the 2000 Ford Windstar. The most recently reported issues are listed below. Please also check out the statistics and reliability analysis of the 2000 Ford Windstar based on all problems reported for the 2000 Windstar.
The contact owns a 2000 Ford Windstar. Upon starting the vehicle, the contact heard a clicking noise from the center of the instrument panel. After a few minutes, the clicking noise stopped. Prior to the failure, the contact stated that the same clicking noise was present when she operated the temperature gauge on the air conditioning unit. The vehicle was taken to a local repair shop where the contact was informed that the motor for the air conditioning unit needed to be replaced. The vehicle had not been repaired. The contact also stated that while driving at any speed, the vehicle would bounce and she could feel vibrations. The vehicle had not been inspected or repaired. The vehicle also stalled intermittently. The idle air control was repaired by a local mechanic. The current and failure mileages were 115,432.
Just pulled into a parking space and put vehicle in park mode when without warning I heard a loud clanking sound. Turns out the transmission failed. I had to get it rebuilt. I have had numerous problem with this vehicle in many areas and have spent a lot of money getting things fixed and replaced on it.
The air flow unit attached to the top of the engine makes a clattering noise. The dealer/service dept. Inspected and described the noise caused by a piston driven mechanism inside this air flow chamber. Apparently this unit helps with fuel efficiency. It needs to be replaced and Ford motor CO. Will not replace it.
At 35 mph engine will make a clunking noise with no warning. Cause unknown. Dealer notified.
A ticking noise continues to come from engine when running and while driving. Vehicle been to the dealer on two occasions, and problem is reoccurring. Feel free to provide any further information.