Two problems related to transmission noise have been reported for the 2005 Honda Pilot. The most recently reported issues are listed below. Please also check out the statistics and reliability analysis of the 2005 Honda Pilot based on all problems reported for the 2005 Pilot.
I was driving the 2005 Honda Pilot about 20 to 30 mph . The time was about 7:15 am. The roads were wet after some misting light rain. I heard a relatively loud noise that startled me. The noise lasted for perhaps 2 seconds. It sounded as if the brakes were inadvertently being applied and grabbing or perhaps something was wrong with the transmission or rear end. I do not remember that the brakes were being applied at the time, but it is possible that they were. I kept driving and was then much more attentive to there possibly being something wrong with the car. About one minute later I heard an almost identical loud sound. I do remember that I was braking at the time, but due to being startle, it is possible that I may not remember such. The vehicle may have decelerated, but to the best of my recollection, I do not believe that the vehicle deceleration was severe. I drove the vehicle to the local Honda dealer. I was told that the mechanic test drove the vehicle and could not repeat the problem and that he could not find anything wrong with the vehicle. Then the service manager talked to me about what possible might have caused the loud noise and he test drove the vehicle with me inside. He directed the vehicle with the left wheels on the pavement and the right wheels on the grass. Then he rapidly applied the brakes. The vehicle made a loud noise and to my memory the noise sounded like the noises I had encountered previously. He said that this noise was from the abs system engaging. I was very please with the attention of the service manager and his customer interaction. Note: the printed paper shop invoice recorded : "customer states it feels like brakes are sticking. Problem is intermittent. " my above incident description provides a more complete description of the incidents.
The vehicle started to "shudder" at medium speed, and two to three days later while accelerating to highway speed the transmission blew up, creating loud banging noises and spilling transmission fluid onto the roadway.