general problems of the 2013 Hyundai Sonata - part 1

My 2013 Hyundai Sonata has a replacement 2. 0t theta ii engine. Recently, it developed a fuel leak that identically matches the description of Hyundai recall recall 22-01-047h (NHTSA #22v-312). I have attached a description of my fuel leak as assesed by a Hyundai dealership alongside a . Pdf of the NHTSA safety recall report to demonstrate that the issue is identical. Hyundai corporate is refusing to acknowledge that this is an identical issue and that my exact VIN group for 2013 Sonatas should be included in this recall. This issue represents a serious risk to life and property that Hyundai is refusing to officially address. They have refused to cover repairs for this issue. Additional info: my car has 124,047 miles on the odometer, but this replacement engine only has about 26,000 miles on it.

I started smelling a little gas in the 20th. And on the 21st it got a lot worse so I took it to the dealership. This is the same place that replaced the engine because it failed and it was a recall. I let them know of the recall and they said it is not covered. They told me it was the high-pressure fuel line that connects to the pump. I have provided a picture of what the tech said.

My vehicle had Hyundai safety recall 227 (fuel tube replacement) completed on December 7, 2022. After the recall repair, the same fuel-system symptoms returned. A Hyundai dealership diagnosed failure of the high-pressure fuel pump and high-pressure fuel pipe and stated the condition was critical and a safety risk due to fuel system involvement and potential fire hazard. Hyundai motor America declined assistance, citing vehicle age and mileage, despite this being a recurring fuel-system safety issue following a recall repair. The vehicle continues to present fuel-related safety concerns, and operating the vehicle poses a potential fire risk. In addition, the estimated repair cost exceeds $2,000, which represents a significant financial hardship for a safety-related defect that occurred after a recall repair. I am submitting this complaint due to concern for vehicle safety and the recurrence of a fuel-system defect after a manufacturer safety recall.

Theres a know recall for this issue. Recall 189 and 227 for Hyundai. Fuel leak right by the regulator on the hose. Mine is doing the exact thing. My motor isnt covered for some reason. Same make and model. So id like to make a complaint and make it know the exact same issue is happening still, 2013 Hyundai Sonata and they wont cover it. So if another recall could be opened to help others. I mean its the exact same issue.

We were sitting in our car at a hardees drive through when we noticed smoke coming out from under the hood. I pulled forward to a parking space and opened the hood. Flames shot up at least 6 feet. I quickly ran a short distance into the fast food place and right near the door was a fire extinguisher, which I grabbed and put the fire out with. The fire burned for about a total of 2-3 minutes, and did not do excessive damage. Coil packs and wiring harness got most of the damage. With the hood closed, you cannot even tell there was a fire. I had the car towed to grayson Hyundai for the recall part, but then entered a claim to Hyundai. Long story short, they stalled me for over a month and then denied the claim. Citing no damage to the cam. Unlike most of the fires with this carline, my car fire was put out very quickly. The recalled fuel line/tube was not damaged much at all. You could inspect the part and see the wear on it and tell it was the culprit. It didn't take a trained mechanic to see this. After I put the fire out and it cooled, I tried starting it, and there was fuel squirting out from the recalled part. There is absolutely no doubt that the recalled part was the cause of the fire. But Hyundai has given me a denial letter that does not state the reason for denial. The Hyundai rep on the phone told me it had to do with no damage to the cam. I then asked, thats because I got the fire out so fast right? and he said no, didn't have anything to do with it. But he lied. First of all, the cam has nothing to do with the cause of the fire. A damaged cam only happens when the fire was long lasting and severe. They should have inspected the obvious recalled part right in front of them. This denial is completely unprofessional and hints of a concerted effort to categorically deny claims. They don't usually have this much evidence, they did this time and still blew it. Had I let it burn to the ground,=approved.

Unknown, caught fire. ??.

So my car started to stall when I started it an when I started goin down the road like it wanted to die. Then I started to smell gas very strong so had a code tester put to my car an I have 6 permanent codes. An not only that im smelling oil strong an noticing big oil spots under my car. So I look under the hood an behind the turbo I see oil behind an underneath the turbo. I definitely didnt feel safe driving but now its not even drivable. I purchased it couple months ago from an individual an I cant belive the amount of problems this car has. Im a single mom an trying to support my family an its hard to now with a non running car. I've put quite a few parts hoping it would fix some of the problems an nothing has. I absolutely love the car an very beautiful but unfortunately to many problems with it. Eninge, gas leaks, timing.

On [xxx], in washington, d. C. , my 2013 Hyundai Sonata experienced sudden engine failure, leaving the vehicle inoperable. My goodwill repair request was denied within 30 minutes, without a proper inspection of the rod bearings (a known failure point covered under the txxi extended warranty) or the fuel pipe recall—a known issue that could pose a fire hazard. Hyundai cited suspected maintenance neglect, but I have documentation of regular synthetic oil changes. Despite having over 200,000 miles, a firestone inspection from September 2024 confirmed the vehicle was in good condition prior to the failure. Additionally, Hyundai theta ii engines are widely known to suffer from excessive oil consumption, a defect that can lead to premature engine failure even in well-maintained vehicles. Hyundai has replaced engines in vehicles with similar mileage under the same extended warranty, yet in this case, no proper inspection was conducted before denial. Safety concerns: the fuel pipe recall was not inspected, raising concerns about whether unresolved recall defects are leading to engine failures or fire risks. The airbag clock spring, covered under Hyundai’s txxa extended warranty, was not inspected, despite the airbag light being illuminated, potentially affecting airbag deployment in a crash. The vehicle failed without warning lights or error messages, creating an unsafe situation. Hyundai’s failure to inspect recall-related issues before denying repairs could impact other affected vehicles on the road. I request that the NHTSA: ensure Hyundai properly inspects recall-related components before denying repairs. Investigate whether Hyundai is improperly denying warranty and recall-related repairs, even in cases where similar vehicles have received replacements. Determine if the unresolved fuel pipe recall and airbag clock spring defect pose broader safety risks. This issue has been reported to Hyundai corporate, but no proper inspection has been performed. Information redacted pursuant to the freedom of informatio.

The vehicle has begun to vibrate/shake badly but manageable. When a code reader was connected to the vehicle both codes 7e9 and 7e8 showed up. Upon researching, information has been found that these specific vehicles have been known for recalls due to fuel hose issues. If I continue to drive this vehicle without the issues being resolved which is not my fault, I jeopardize my son and I’s lives as well as any potential future passengers.

After starting, got a warning stating check hybrid braking, do not drive. When going forward, brake pedal went to floor, heard heavy grinding noise and vehicle stopped accelerating. Had to use the emergency brakes to avoid an accident. Hyundai says they can’t find a problem. Now I can’t even drive it back to the dealer! did an internet search and many other hybrid owners have reported the same issue. I just want to have Hyundai buy the car back at this point. It only has a little over 50,000 miles on it.

2013 Hyundai Sonata engine caught on fire after being replaced twice.

My low pressure fuel hose has a leak. The amount of gasoline that is spraying on my spark plugs and engine is concerning. The gas fume smell coming in through the vent was horrible. After finding this leak I came to the conclusion that I am very lucky my car didn’t catch fire while I was driving. For some reason there is already a recall in place that includes my vehicle year but does not include my vehicle VIN. How do I get my vehicle included in this recall so that it can get repaired? the recall in question is NHTSA number 227 or 22v – 314. At this time, the car is sitting in my driveway and I am not inclined to move it until I know it can get repaired. At that time, I will have it towed to the dealership.

While accelerating on the highway, several warning lamps (battery, engine, others that I forget) came on. When I pulled over the hood was smoking, and a fire flared up after I opened the hood. My son and I escaped the car with no injury. Still waiting for report from insurance company.

While driving the car at freeway speeds it died and quit running, and the engine compartment began smoking, and a fire ensued under the hood. Gasoline could be smelled before it started fire.

Wires, reverse osmosis system unauthorized and unknown.

The engine went into smoke and caught on fire. Resulting in damage to the vehicle ultimately causing to be totaled.

Car smells like it’s burning, been told it’s oil. Dealership after seeing leakage on the engine replaced the valve gasket. Car still smells like it’s burning and apparently there is no leaking. I went to the same dealership to inform them and they recommended replacing a hose but not a guarantee it will fix the overall problem which is smelling of burning. I’m concerned! I’m 37weeks pregnant and don’t want to inhale burning or any other chemicals pre and post postpartum with a newborn.

What component or system failed or malfunctioned, and is it available for inspection upon request? the car continues to have inconsistent acceleration, hesitation, and sometimes lurches forward. On two occasions, the car felt like it was just going to turn off while driving. I was driving about 75 mph on i295 and driving about 15 mph on a residential road during the second occurrence. How was your safety or the safety of others put at risk? I feel as though I am not in complete control of the acceleration but am mostly concerned with the car stopping on it's own. I am very scared I'm going to be hit by the car(s) behind me. Has the problem been reproduced or confirmed by a dealer or independent service center? yes. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? I have an appointment in October for the car to be evaluated by a dealer. I hope it doesn't happen again before then. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? the only time a warning lamp came on was during the second episode when the car felt like it was going to turn off; the engine light came on and immediately off.

My 2013 Hyundai Sonata lost acceleration power while on the road requiring an emergency departure from the road and it fails to acceleration beyond. Placed vehicle in park and attempted to proceed home but was only able to drive 5 to 10 mph max creating a dangerous situation for my fellow commuters and myselt. After about a few block I let the vehicle cool down and attempted to proceed home. The car would only go up to 5 mph requiring me to avoid rear end collisions. Ultimately, requiring a tow vehicle to bring it home. Our neighbor indicated it is the map sensor which was changes with no improvement to the car's acceleration issues. Checked all the fluids and assured they were correct. This vehicle has place me and others in a dangerous and potentially fatal situations.

This incident singled happen in a 20 or so miles on my way home commute, no freeway drive. I was driving pulling out of a parking street when I notice the vehicle tendency to pull me forward, even though I was preparing to stop. It continue to have this issue at a stop sign and traffic light. At first it was mild pull as if you are being towed. Sporadic pushing forward, but when I turned to the left I notice that the engine pick up speed on its own and the issue was exacerbated on turns to left and right. The issue continue to the point I stayed at a safety distance from other cars and the pull began to be more aggressive. I was driving slow at that point. With hazards lights on. On arrival to my home driveway and upon putting the car on park the engine rmp jump so high that scared me! the car sounded as if it would take off by its self. I had the foot on my brake and did not pump at that point. I took car to the dealership the next day and it continue to pull at sporadic times I drove slow and cautiously . Noticing that the pull got worse driving on a straight street versus the day before only on turns having more aggressive forward acceleration pulls. The dealer has check the car and has not been able to detect the problem with computer codes and apparently have not been able to reproduce the issue after driving the car. The mechanic, told me to take pictures of engine light if when I drive it has issues, and the light comes up. But not other solution was given.

While driving car engine compartment caught on fire. Unknown to me two passing motorist alerted me I pulled over at that time engine was on fire. Fire extuginsh using extuginsher. Car towed to major Hyundai of stroudsburg 1534 north main stroudsburg PA.

He99 p cabin filter dr break lightv air filter oil leak poss oil pan. Now having engine problems and my car was taken to pennsylvania. My car started smoking.

Fuel line is leaking as with the recall, but my car shows that it is not part of the recall 189. . . Fuel tube. Problem is the same as the recall campaign 189.

2013 Sonata. Constant oil consumption. Had replaced the oil pan and piston, oil caps, pvc valve. Car stalled twice and kept getting check engine lights popping up. Turns out the engine is defective and needs to be replaced. The car is starting at my mechanic right now and trying to figure out how to get it to Hyundai dealer so the engine can be replaced. The car is unsafe to drive right now. My son has the car.

I have owned my car about a year. There were no problems from the beginning but just a few days ago I was waiting in my car and turned the heater on. The strong smell of fuel came through the vents I immediately shut off the vents and took the car home and did not drive it for a few days. After a inspection from myself to see if I could find the issue nothing was found and so I took the car into a shop to have them inspect it. They quickly found that the metal high pressure fuel line was leaking at the connection to the fuel pump. They said I was lucky that the car had not caught on fire during the drive to the shop as the leak was right near the spark plugs and the fuel vapors were very strong. They tried to reestablish the seal and the leak is worse now. The car is undrivable and I will have to replace either the fuel line and/or the fuel pump.

My 2013 Hyundai Sonata caught fire yesterday after the car stalled at a red light - car is totalled - I am just hearing about this now that numerous car like mine have gone up in flames. I am devastated.

Everytime I put fuel in my car I get a strong gas smell outside and inside my car. I’ve looked to see if there is a leak and do not see anything. Looked to see if there are recalls and shows there are 8 but when I put VIN in. There is no recalls. Don’t know if the have been taken care of alright or I never had them on my car.

The low pressure side fuel line on the vehicle has cracked and has a hole in it. Just above the back of the engine. Hyundai has issue a recall on this exact problem mid last year. However they say there is no open recall for my vehicle. This tells me Hyundai is not being honest about the amount of vehicles this has affected. When trying to reach Hyundai about this issue I simply get told there is not a recall for my specific vehicle. Vehicle stalls while driving and is very hard to start up after fueling. This is an extremely unsafe vehicle do to the strong possibility of fuel leaking on to the engine or exhaust while running. I find it completely irresponsible of Hyundai to potentially put someone’s life at risk by not including all vehicles of the model any year in their recall related to this problem. There was no warning of this issue other than the vehicle stalling or running rough at stops and not starting correctly after refueling. I have pictures to prove the issue. Please look into this matter seriously and hold Hyundai accountable for recalling all vehicles with this potential problem. Hyundai appears to be excluding or not being honest about the amount of vehicles that need to be fixed in their recall. Vehicle can catch fire and people can lose their lives cause of this negligence.

I had my car recall fixed on 12/10/2022 at the burns Hyundai in marlton NJ. It seems to have failed when I parked my car it smelled like gas and I got out and see gas all over the ground. They were supposed to fix 2 recalls on my vehicle. My gas was empty after I had just filled it. My car would not start. It cranked but didn’t start. There were no warning signs.

Received recall NHTSA recall number:22v-312, fuel hose replacement. Contacted Hyundai of bowie , service 301-850. -6802. The scheduler explained that the company does not have a plan to correct the problem. The problem has not been confirmed by a dealer or independent service center. I received several recall notices and the response never changes "no remedy available.

The car caught on fire while my family was driving it. Nearly killing them in the fire. Witnesses say the fire started underneath the car then went to the engine. There is a TSB recall 227 on those types of cars indicating the fuel tube needed replacement. This car was serviced last in September with an engine replacement at Hyundai dealership. That day the check engine light came on. Police was called, insurance is investigating. Have not contacted manufacturer.

We were travelling from minnesota to arkansas to see our family for thanks giving on 11/24/2022. Car engine starts blinking and engine started to make rattling noise. Took exit and pull over our car in one of the gas station. It was closed, this was our fisrt road trip and first time in iwoa. Called insuarnce and towed our car to o'reaily auto part. They found out the error code p1326 which is realted to engine issue. Looked for nearby Hyundai delarship and booked hotel near them. We went to Hyundai delar at 7:00am on Friday 11/25/2022. We told them what happened. They told us they will check in our car. We waited from 7am to 1:30pm our car was still outside. At 2pm service manager came and said they cant check our car. We booked rental car ourself and decided to come back home. We forgot our apartment key went back to get it and they had alreday started to dignonse our car thinking we are gone. Service guy told me thats engine failure every Hyundai is facing now. My car have 61k miles on it and I bought it in 2020 from Hyundai dealarship. I still have 9k loan to pay this car and I cannot afford new car or new engine. I do not have car now and they are saying it can take months to repair my car if it gets approved for engine replacemnet. Hyundai is playing with my life and put me in depression. I have no option other than to cry. I am feeling so helpless now. Nothing and nobody seems helpful. I try my best to do anything I can and I am just waiting for coming Monday for Hyundai to make excuse to not fix my car. Hyundai is playing with lots of people life. This might be small for them but not for a working people liks us. My life is messed up because of them. I cannot sleep at night and I have been calling everywhere if I can get help.

I called circle Hyundai over a month ago to schedule an appointment for recall #22v-312 and was told I'd be called when the part arrived. I called back 2 weeks ago and was told it wasn't in yet. I called today, 11/18/22 and was told the warehouse wasn't releasing parts for this recall. My notice states to call for an appointment for this to be changed out. As a safety manager myself I'm now being put in harms way if this part fails and catches on fire. Not a happy Hyundai customer!.

I was driving my daughter’s 2013 Hyundai Sonata hybrid to the gym early one Sunday morning. I pulled into the parking lot to park the car. When I stopped to put the car in park the car suddenly accelerated and I drove through the glass wall of the gym. The car accelerated through the gym, hit a metal pole , and crashed into a wall on the far side of the gym. The front end of the driver’s side corner was smashed in and my airbags did not go off.

Was driving down the highway doing about 70 miles per hour engine just flats out stalls on me. Was trying to merge over to get out traffic had no power and almost got hit by semi. Wait 5 minutes and restart car. Car started making clicking noise and gave it gas went a little bit and stalled out and would not restart. Contact a manufacturer said there is an issue with the engines but does not know if it qualifies for their extend warranty.