Oil Pump Problems of Hyundai Sonata Hybrid

While trying to accelerate at freeway speeds (50-60mph), the "eco guage" revs up but the car will not accelerate - slows down in the middle of traffic. The oil pressure warning lamp flickers on and off as well. After the car is stopped and turned off, the car functions normally. Mechanics are unable to retrieve any codes from the system. The car has intermittantly dropped into this mode at least 10 times since we first experienced the problem in July 2018. The problem occurs at freeway speeds causing the car to rapidly decelerate in fast moving traffic with no advance warnings. This situation requires immediate evasive action to remove the car from high speed traffic lanes so it can be shut down and towed to the Hyundai dealer. My wife and I consider this a life-threatening situation as it has occurred in places such as the bay bridge (with no shoulder) and a lengthy underwater tunnel (again with no shoulder). We have taken it to the Hyundai dealer service shop four times. They have replicated the problem and have tried various repairs - replace transmission oil pump, replace inhibitor switch, install new auxilliary battery, and - finally - replacing the transmission. Even after the transmission replacement, the car shut down while the mechanic was test driving it and provided a code to replace the crankshaft position sensor. The mechanics still are not certain they have fixed the problem. It appears as if Hyundai is aware of the problem as their technical support staff have a protocol for repairing the car. Given the intermittant nature of the problem, the fact that it occurs at high speeds, and the potential danger of having your car rapidly decelerate on busy freeways, I think this is a safety issue that needs to be addressed by Hyundai. Attached is the original service record that describes the problem (date 8/6/18). The most recent occurrence was 11/27/18.

See all problems of the 2012 Hyundai Sonata Hybrid 🔎.

Car stopped in the middle of local street road and not able to be driven to move to side of road. Car towed to delaer for repair. Want to warn about this danger to other owners. We were lucky since no one was behind us when the car immediately stopped in the middle of the road. Car was repaired by delaer as follows. Tech scan codes and found codes u1007, p1775, p1774. Tech check a/t fluid, red color, smell normal. Reset codes, codes come back. TSB provided by tech line. Tech follow TSB#14-hc-003, result to replace oil pump control unit and recheck. After replacing oil pump control unit, same problem present. Tech replace oil pump, and found open yellow wire from oil pump unit to oil pump. Car runs normal and no codes present at this time. Tech try to put the old oil pump and pump module back in, problem happened again. Tech confirm the pump and module are bad. New oil pump and module reinstalled. Car under warranty and repair was successful. Delaer did a good job keeping me informed on the progress, even though it took longer than expected to repair the car.

See all problems of the 2013 Hyundai Sonata Hybrid 🔎.

The contact owns a 2012 Hyundai Sonata Hybrid. When shifting into reverse or drive, the vehicle jerked violently. In addition, while driving 15-20 mph, a chime sounded and the ¿safely stop and do not drive¿ warning message appeared on the message board. The failure recurred multiple times. The vehicle was taken to a dealer where it was diagnosed that the oil pump or the computer module failed. The vehicle was not repaired. The vehicle was not included in a manufacturers recall that was related to the failure. The approximate failure mileage was 71,415.

The contact owns a 2011 Hyundai Sonata Hybrid. The contact stated that while driving approximately 35 mph, he attempted to brake and all the warning lights illuminated. The contact also stated that the vehicle stalled and could be restarted. The failure recurred on fifty occasions. The vehicle was taken to a dealer where it was diagnosed that the transmission, the electric motor, and the oil pump needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 66,000.

See all problems of the 2011 Hyundai Sonata Hybrid 🔎.