general problems of the 2017 Hyundai Tucson - part 2

#1. This vehicle uses a lot of oil !!! it burns through it like crazy I have to check the oil every other day. #2. When I come to a stop while driving and give it gas to take off it wont go !!!!! it hesitates and when it does go it lunges forward!! this is a huge manufacturer problem not a buyer problem. The engine is junk. ! 3. I’ve called numerous places to get help. This car needs to be recalled. This is a huge safety violation. It doesn’t wanna go when you give it gas and when it does, it lunges forward that can cause a huge accident on the highways. This car was made in china. It is junk. I’ve called to get help with this issue and no one wants to help. Nobody returns my calls and I’ll Hyundai wants to do is it even more money out of me when this isn’t my fault the car is junk. For safety concerns I would like someone to call me at [xxx]. This car needs to be recalled and my daughter has one. It’s doing the same thing except hers is a lot worse. Hers is further advance where it’s actually stalling in the middle of the road while driving huge safety violation. Information redacted pursuant to the freedom of information act (foia), 5 u. S. C. 552(b)(6).

Engine is burning oil causing the catalytic converter to clog and fail. Hyundai dealership told me after I had the car towed to them for repair on 12/30/2025 that the catalytic converter had already been replaced before in March 2024. I had purchased the car from another dealership March 2025 and the catalytic converter replacement was not on the car fax. I was also I formed by the hyandai dealership that my car has an extended warranty of 10 year/150,000 miles on the engine due to the known oil consumption issue. My car has 131,000 miles. I was told hyandai will make it very difficult for engine replacement since I’m a second owner. There needs to be a recall immediately.

Engine lost power suddenly on the highway. Vehicle entered limp mode and became limited to 45mph and reduced acceleration.

The contact owns a 2017 Hyundai Tucson. The contact stated that while driving at an undisclosed speed, an abnormal pop sound could be heard coming from the engine. The oil warning light was illuminated. The contact was about to merge to the side of the road when the contact noticed a glow on the underside of the vehicle. The contact then pulled into a parking lot, smoke was emitting from under the hood, and entered the vehicle through the a/c vents, and noticed the flames under the hood. The contact stated that the heater was turned on, and the contact immediately turned off the heater. The contact opened the hood and used a fire extinguisher to extinguish the flames. The fire department was called to check the vehicle to make sure the fire was extinguished. The fire department used a thermo reader to make sure that there was no more risk of a fire. The vehicle was towed to the residence. The contact towed the vehicle to the dealer, where it was diagnosed that the engine had failed. The contact was informed that the vehicle had an open recall pending: NHTSA campaign number: 21v727000 (engine). The dealer informed the contact that since the recall was not performed, the engine had failed. The contact stated that he was the second owner and that the vehicle was purchased in 2022. The contact was unaware of the recall at the time of purchase. The dealer refused to complete the recall repairs. The vehicle was not repaired. Most recently, the contact was informed that the connecting rod failed and punctured the bottom end of the engine. The vehicle remained at the dealer unrepaired. The manufacturer was made aware of the failure and denied the recall repairs. The failure mileage was approximately 107,000.

Am submitting a safety complaint regarding my Hyundai vehicle due to repeated engine power loss (limp mode), excessive oil loss, and a denied engine recall replacement. I initially brought my vehicle to the dealership after experiencing engine power loss/limp mode, engine oil loss, and illuminated check engine warning lights. The dealership confirmed that my vehicle was covered under an engine recall and stated that the recall procedure was completed. As part of this process, the dealership performed an engine combustion-related service and charged me approximately $1,600. After this repair, I drove the vehicle for approximately 1,000 miles. When I returned the vehicle to the dealership, the vehicle entered limp mode on the same day it was brought in, and the check engine light was illuminated again. The dealership advised me that the vehicle had lost an excessive amount of engine oil during the 1,000-mile period. Due to the continued engine issues and oil loss, the dealership requested a full engine replacement under the recall. However, Hyundai denied the engine recall replacement request. The vehicle’s repeated loss of power, excessive oil consumption, and limp mode create a serious safety concern, especially while driving at normal road speeds. I am concerned that the recall remedy was ineffective and that the denial of an engine replacement places drivers at risk. I am requesting that NHTSA review this matter for potential safety defects and improper handling of a known engine recall issue.

Car engine seized and lost all power going 60mph down the highway at night with my child in the back seat. I have poured quarts and quarts of oil in this vehicle because it burns oil at an alarming rate until it eventually runs dry and the engine seizes. This is extremely dangerous and luckily my child and I were able to drift to the side of the road without harm and injury. Very discouraging that there are thousands of these cars and engines on the road that can literally seize up at any minute. Maintenance was performed and kept up with. The oil pressure light had been flashing when the vehicle turned but was flashing even when oil had just been changed. These engines are dangerous and have people in a financial hard spot. I still owe $16k on a car I can no longer drive and that Hyundai is saying due to owner maintenance will not get an engine replacement. The facebook group Hyundai oil consumption test has thousands of people dealing with the same exact issue on these cars and engines.

Severe oil consumption. The vehicle eats the oil at an alarming rate. Having to fill the oil tank very often and the engine light has been on. It is affecting acceleration at 30mph where the engine warning light will flash. It also completely dies while driving. Very unsafe and needs to be resolved.

I’m submitting this complaint to report what appears to be a serious safety-related engine issue in my 2017 Hyundai Tucson sport 2wd with the 1. 6l di turbo engine [t-gdi gamma]. I’m aware of NHTSA recall 21v-727, which covers 2017 Hyundai Tucson models with the 2. 0l engine for premature engine bearing wear. The symptoms covered by that recall are nearly identical to the symptoms my vehicle is now showing. My VIN shows no open recalls or service campaigns on Hyundai’s website, but the problems I’m experiencing match those found in many other consumer reports for this same year, make, and model. My vehicle has only 80,000 miles and has had regular maintenance. Examples include loud knocking from the engine that rises and falls with rpm, and metal shavings in the oil. One complaint that reflects the same pattern can be found in NHTSA id 11680114, which describes engine knocking and metal debris with no warning lights or alerts. My vehicle has also shown no warning indicators. These issues pose a safety risk because they can lead to sudden engine failure while driving. Based on the volume of similar complaints and the overlap with the existing recall, I’m concerned that the defect may affect more than the engines currently covered under 21v-727. I’m requesting that NHTSA review this matter and determine whether Hyundai should extend or expand the recall to include vehicles equipped with the 2017 Hyundai Tucson sport 2wd 1. 6l di turbo dohc 4cyl. Please investigate this issue and hold Hyundai accountable if these defects extend beyond the vehicles already listed.

I am writing regarding a serious incident involving negligent automotive service performed by jiffy lube store #687. On October 24, 2025, I took my 2017 Hyundai Tucson to this location for a standard oil change. I trusted that the service would be completed properly and safely. However, on November 21, my vehicle’s oil lamp unexpectedly illuminated. Concerned, I returned to jiffy lube on November 22, where employees informed me that they had “sealed the small leak and topped [my] oil,” adding that I was entitled to two top-offs between oil changes and “should be good for two weeks. ” tragically, the very next day, November 23, the oil lamp flashed again. My vehicle then shut off while I was driving, with my children in the back seat. This was a frightening and dangerous situation for all of us. I am now left confused, stressed, and unsure of the full extent of the damage.

While driving on the interstate at highway speed, my 2017 Hyundai Tucson lost power without any warning lights or prior symptoms. The vehicle experienced an immediate loss of propulsion while I was traveling in traffic, creating a dangerous situation because surrounding vehicles were also moving at highway speed & I had to quicky maneuver the vehicle to the shoulder with no power. The vehicle had approximately 73,861 miles at the time of the failure. After the incident, the vehicle was taken to a Hyundai dealership and diagnosed with a burned exhaust valve requiring replacement of the cylinder head & valve. The estimated cost of repair provided by the dealership was approximately 7550. The vehicle had no prior warning lights or symptoms before the sudden loss of power. A sudden engine failure resulting in loss of propulsion at highway speed presents a serious safety risk to both the driver and surrounding traffic. This was an extremely dangerous failure.

I recently purchased vehicle and when checking recalls from my local Hyundai dealership I was advised that there was two previous attempts to have engine replaced due to knocking and it was denied this recalls is the 209 I escalated to Hyundai corporate and after taking to a Hyundai dealership and paying for a diagnostic test they advised car doesn't have oil pressure and the oil pump needed replaced and Hyundai corporate denied repairs saying this didn't pertain to recall 209 because my engine is a 1. 6 liter and it was ok only to the 2. 0 engines, I would like to report this and ask for help please.

I know there is a re-call for my vehicles engine and year with model. I am having serious issues with my vehicle related to the recalls for the same year and model. I feel unsafe driving my vehicle and now I do not know what to do.

Oil consumption problem caused vehicle to go into limp mode on freeway. Manufacturer states 1qt loss every 1000 miles is acceptable.

Vehicle is burning through oil.

Sensors something to do with the motor and not sure where the other sensors is related to could be the motor as well. The safety was not good due to it shut off in the middle of traffic and making wraddling noise. I took the vehicle to the dealership where purchase from. They have done nothing besides fixed one thing that I know of supposed to been the surpension. But the other problems was not fixed no it has not been inspected by anyone the warning lamp come on and just blinking none stop.

I purchased a cpo 2017 Hyundai Tucson in June'22 and brought it in for engine stuttering, the car stalling in intersections and was told they couldn't duplicate the problem. I emailed and brought the car in again and still noting was rectified. I've made the oil changes, changed spark plugs, flushed the engine in July and got new oil and everything looked at and in October the engine seized while my husband was driving to work: no oil lights on no engine lights on. Neither Hyundai or the extended warranty will help. My VIN didn't come up in a recall but there's too many problems with other 2017 I would hope they'd look again and help their customers.

- kept regular 5k-6k oil changes since 2022 when I purchased the vehicle -took the vehicle to a Hyundai dealership, multiple times, to ask about the engine stalling at a stop or slow turn, and/or jerking. -July '25 new oil change and flushed engine -October'25- no engine or oil lights. Engine seized and needs to be replaced. - VIN didn't populate recall but the symptoms are the same.

I've taken the vehicle to several mechanics for engine-idling when turning, going up-hill. I've purchased new plugs, lines, engine cleaners, no-one can figure it out. The oil now has engine shavings even though the oil was recently changed. The car broke down today.

Excessive oil consumption leading to catastrophic engine failure.

The contact owns a 2017 Hyundai Tucson. The contact stated that while depressing the accelerator pedal, the vehicle failed to respond while stopped at a red light. A dealer was contacted. The vehicle was taken to the dealer to be diagnosed; however, the diagnostic result was unknown. The vehicle was not repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 95,000.

The auto has 112,000 miles and is using oil excessively. A quart with every gas fill up.

Engine burning oil. Had 2 oil consumption tests and failed both. Had engine combustion chamber cleaned and still burning oil. Hyundai denied new engine.

The 2017 Hyundai Tucson I owned had the engine fail (internal bearing failure) rendering the car basically worthless. Hyundai has multiple recalls on this type of engine. My car had 120,000 miles when the engine failed. Hyundai refused to offer any assistance on this, fully knowing that these engines have had thousands of problems in australia and the us. This is a problem they know exist and they are doing nothing!!!! they need to admit the problems and help consumers when this happens instead of trying to weasel out of any responsibility. Thanks.

My 2017 Hyundai Tucson has completely broken down will not go into reverse had a diagnostics at Hyundai. I thought it was going to be covered because of the class action suit. My car apparently was not in the recall or the suit. I don’t understand I have the identical problem of the dual clutch transmission issue. I’ve tried to get Hyundai to do good-faith repair they refused. I’ve contacted carmax where I purchased the vehicle. They had the car when the lawsuit was finalized I didn’t know anything about the lawsuit or the problem with the vehicle. I’ve had the car for five years it’s at 85,000 miles. I don’t know what to do.

Unknown believe it engine was replaced due to engine knock.

Had an oil change on September 29th. The mechanic brought to my attention metal shavings in the oil and advised that I should get rid of the car because it won’t last much longer. It drove fine for a day until the next afternoon I was driving on the highway with my children and the engine started knocking loudly. The car stopped accelerating past 45 mph. I was close to my house fortunately but barely made it as it sounded like the engine would blow. It is now sitting in my driveway still knocking when I start it and don’t feel safe driving it anywhere. There were 0 warning lights. I was not aware of the engine issues these cars had until I did some research and looks like it’s very common. Seeing some people had luck getting replacement engines in the past and many others not. This needs to be addressed and Hyundai needs to be held responsible for the awful oil consumption issue resulting in failing engines. We should not have to provide proof of maintenance when clearly this is an issue regardless.

My abs has been sticking and finally the pad broke off. My car made a squealing noise everytime I drove it. I had parked in my driveway and there was a piece of metal on the ground. I showed it to my son, he took the tire off and said it held my abs brake pad on to my driver side rear. He is a master tech for Subaru. I just haven't had time to take it into Hyundai. It has stopped squealing, but my abs brakes no longer work.

About every 500 miles I have to add about a quart of oil. I brought my car to mcdaniels Subaru for maintenance on my car. My son is a master tech there and I know he is very thorough. My contract lets me go there also. So he checked the dipstick and it was below a quart of oil. He did change the oil change. I cannot drive a long distance without carry a large container of oil. He has warned me not to let it get low again or the engine will seize. This car gets all its regular maintenance on time. I have a contract to do this. The dealership had all the maintenance records at the time I purchased it. It has been very well maintained.

Engine failure even though this car has always had oil changes at 110,000 miles. I would like the company to fix this since I am not the first to complain about this. I still have the car parked.

My engine check engine light and than a warning light came on saying not to drive it and I took it to be repaired at a shop and a hyndai dealer and they told me my engine needed to be replaced even though I always serviced my car. It has 103,000 miles on it. It is the same problem as the other person that reported this problem. The other models were recalled but not this one. Im sure by now you know there is a problem with this engine too. It should be replaced by the company!!.

Excessive oil consumption, full synthetic oil last less than 2000 miles. Transmission takes some time to respond when start driving from a stop. Car shake a bit.

Burning oil. More than a quart every couple hundred miles sometimes much more than that. Very bad burning oil smell coming from engine into the inside of my car. I feel sick everytime I drive from breathing in fumes. Need oil consumption test ASAP.

My 2017 Hyundai Tucson has been chonking out and having acceleration problems. I thought it was because of ac running. When I took it in for inspection my mechanic stated it was misfiring. I am meticulous about routine maintenance (I. E. Tire rotation and/or replacement, oil change, inspection, etc), as well as whatever if any repairs are needed. I immediately reached out to my local Hyundai dealer but they never responded. It should be corrected by Hyundai and a recall issued. After researching the issue I see I’m not the only one with a problem. The 1. 6 l engine should have been recalled because apparently the same turbo engine in the gdi model was. I have all my maintenance records to support my claim. Come Hyundai!!! I thought you stood behind your vehicles?????.

Electric,.

Every time I get the oil changed I have to add 2-5 quarts of oil in between changes. I had the catalytic converter replaced 3 years ago and now I have to do it again. I’ve had nothing but issues with this car and oil consumption. I shouldn’t need another catalytic converter again after only a few years. I’m doing my 3rd oil consumption test right now.