Three problems related to other fuel system pump have been reported for the 2005 Jeep Wrangler. The most recently reported issues are listed below. Please also check out the statistics and reliability analysis of the 2005 Jeep Wrangler based on all problems reported for the 2005 Wrangler.
When refueling my Jeep, fuel was expelled from the filer neck at the same time the fuel pump cut off automatically. I was covered in gasoline this time after the fuel was expelled from the tank. This has happened on every refill starting about 6 months ago but the first time I have been doused with fuel. The Jeep dealer indicated that a recall had been initiated on hundreds of Wranglers but not the 2005jeep Wranglers for the same problem. This is an incredibly dangerous situation and the consumer needs your help!! many online articles from organizations like edmunds and consumer reports has indicated this is a serious problem and the problem needs to be identified by your organization and Chrysler needs to recall the vehicles.
Recently purchased the Wrangler used. Fuel spill every time you fill the gas tank. When the fuel pump clicks off fuel shoots out the fill spout.
At any refueling, before the fuel pump auto shut off is engaged, there is fuel spit back out of the fuel filler. It runs down the corner panel and behind the left rear fender flare, as well as onto the ground. Depending on what setting you have the pump handle set to (high, medium, low), depends on how much fuel is spat back out.