general problems of the 2008 Mercury Milan - part 1

08 merc Milan abs did not work and brakes failed almost causing major accidents. I used e brake to stop. Brakes went to floor. Been calling for and dealerships for recalls I find out now about abs malfunctioning noone will fix or get back to me. Leaking brake fluid all around abs module now. Dealerships saying they not fixing abs even on recalls. Ford dealership in east rutherford NJ.

The abs brake function checked out during the recall window on Nov. 2 of 2021. The Ford dealer mechanics purged the brake system with fresh fluid and tested the function. Tested ok. The car was used without issue until recently and now the brake pedal goes down nearly to the floor before the brakes engage. It is shocking at first and once used to that the driver will pump the pedal twice for a firm pedal. A recent visit to a Ford dealer to diagnose the issue revealed that the recall is closed and that there is nothing they can do unless I pay the approximately $1000 to replace the abs hydraulic module. My complaint is that Ford customer service wants me to pay for this and then submit the invoice to them for review. Wow, I'm not going to do that, since there is no guarantee of reimbursement. This is a known safety problem that is not being addressed appropriately. I'm a mechanic. They could send me the part free of charge for a sane resolution. I'd eat the labor charge.

The gas pedal gets stuck at the top when I go to press down on it allowing the car to keep driving when I am trying to stop the car.

Brakes are failing even after they have been serviced. Unsafe car to drive.

Was not able to drive my car because you had to press the breaks all the way to the ground in order for the vehicle to attempt to stop. A recall was issued for the hydraulic breaks in 2019 and no parts were available for almost a year. Car has been at the dealership being repaired since August 12, but now they are telling us that the hydraulic breaks issues has caused the break master cylinder to fail - leaving the car unsafe and undrivable but they are expecting us to pay for the replacement of the master cylinder when the dealership openly admitted this was directly caused because of the recall.

I took the vehicle in earlier this year for the recall on the brake system. They bled the brakes and said it was fine but now the brakes are just like they were before taking it in. I would assume that the hcu is bad but they did not want to change it out when they had it.

The contact owns a 2008 Mercury Milan. The contact stated while driving 25-30 mph, the brake pedal was depressed but went all the way to the floorboard and failed to respond. The contact was unsure whether there was a warning light illuminated. The contact stated that she coasted the vehicle on a hill and turned off the vehicle. There was no warning light illuminated. The vehicle was towed to three different independent mechanics who diagnosed that the braking system had failed. However, the failure was unrepairable. The contact became aware of NHTSA campaign number: 19v904000 (service brakes, hydraulic) which she associated with the failure. The dealer was notified of the failure and informed the contact that the remedy was not available. The vehicle was not repaired. The manufacturer was notified of the failure and confirmed that the remedy was not yet available. The failure mileage was approximately 97,000.

For several years, my vehicle has had an issue with "extended brake pedal travel," making it more difficult to come to a stop with a reasonable effort, and increasing the likelihood of an accident. My vehicle has already been repaired for a prior recall regarding "extended brake pedal travel" (this "repair" did not fix this problem; in fact, it apparently passed the Ford-developed test, thus warranting no significant repair. My father is a Ford automotive technician and he was also surprised by this result. I suspect the Ford-developed "test" to determine whether there is indeed a problem was developed in Ford's favor and does not ensure the safety of the customer/driver.

The contact owns a 2008 Mercury Milan. The contact stated the vehicle was repaired under NHTSA campaign number: 19v904000 (service brakes, hydraulic) however, while she was driving 10 mph, the brake pedal was depressed but felt soft and remained on the floorboard. The contact stated she continued to pump the brake pedal until it became firm. There were no warning lights illuminated. The vehicle was taken to the dealer who diagnosed that the parts used for the recall repair had failed. The manufacturer was notified of the failure and informed the contact that she would be responsible for the cost of the repair. The vehicle was not repaired. The approximate failure mileage was 68,000.

Nhtsa campaign number: 19v904000 manufacturer Ford motor company components service brakes, hydraulic vehicle regarding complaint: 2008 Mercury Milan vehicle VIN: 3mehm08138r665795 good day, in September of 2021 I took the above mentioned vehicle in for the above stated recall regarding the hydraulic control unit. The vehicle was taken to westlie motor company 500 s broadway minot, nd 58701 (701) 852-1354. The vehicle was tested and did in fact fail the test and I was informed the replacement part would be ordered promptly. After two months of no calls from the dealership I stopped in and was told they had no idea about the part. I was assured it would be looked in to. The first week of December I was called and requested the vehicle be brought in for the recall service. I took the vehicle in December 6th and after two hours was notified service was finished. Upon driving home I immediately noticed the problem had not been fixed. I returned to the dealership upon inspecting the vehicle having noticed the no obvious repairs had been done. Demanding explanation I was told that it was a miscommunication and recall work had not been done. Only a brake flush and cap replacement. I was then again told that they were not sure where the part was or when it would arrive. I then escalated a complaint to Ford motor company ( 1-866-631-3788) case # cas34759999-g2s5y2. I was assure Ford would call the company and inform me intermediately as to the situation and a solution. I received no call back and I again phoned in January with the same result. I was told they would look into it and call me back. I again called today Feb 1st and spoke with Ford and was told the same thing with no solution given. I have been dealing with this recall for nearly 6 months. As per your website states, a company or manufacturer must fix or offer a solution in a reasonable time period. I feel 6 months is long enough to find a part. Please help. I want my car safe for my family.

The contact's mother owns a 2008 Mercury Milan. The contact stated that while depressing the brake pedal, the pedal depressed to the floorboard without warning. The contact had initially taken the vehicle to an independent mechanic who informed her that the vehicle was included in NHTSA campaign number: 19v904000 (service brakes, hydraulic). The contact had taken the vehicle to a dealer where the recall repair was performed. Upon return of the vehicle, the contact stated that the brake pedal again depressed to the floorboard without warning. The contact immediately took the vehicle back to the independent mechanic where he inspected the vehicle; however, the vehicle had yet to be repaired. The manufacturer was notified of the failure and they informed her to take the vehicle back to the dealer. The vehicle had yet to be repaired. The failure mileage was approximately 53,000.

I have been notified by Ford motor company several times about the recalls on my vehicle. One recall is for airbags. I went to the closest dealership new my small town and thought they issued the fix, only to learn later that they just disconnect the airbag light. The second recall is for the brakes, I have been calling since January of 2021 to request a service date only to be told they have no knowledge of the recall. On March 30,2021 I finally got a service date and express to the representative on the phone to assure that she knew it was for the break recall 19s54, she assured me the knew. I took off work that morning for by service appointment only to be told that they did not have the equipment to fix the issue. I was told to call other dealerships and turned away. I called 4 surrounding dealerships with in a 50 mile radius only to be told no one can perform the procedure. I then called Ford customer relationship center for assistance. She called one other dealership that said they could not fix the issue as well. April 2020 I receive a letter from Ford motor company saying parts are now available to repair you vehicle. Called dealership 5/17/2021 they still cannot fix issue nor have any information on who can. Help! Ford motor company, how can I get the recalls fix if none of your dealerships in my area are capable of repairing them?.

Nhtsa recall number19v904 recall statusrecall incomplete, remedy not yet available summary on my vehicle, a valve in the hydraulic control unit of the anti-lock braking system may be stuck open. Took it to the north park Lincoln dealer on 23 Apr 2021 and they don't have the part for this recall. Said my inspection for this recall failed and they notified Ford. It's been over 60 days and I am still waiting on this part. My car is not safe to drive as my brakes are very low and its taking longer to slow the car down so my car is basically not being used for fear that the brakes might go out. No one seems to be able to gove me an answer as to when this recalled part will be in. I received the recall letter from Ford telliing me about this recall but letter also said the parts were available and that is why I took it to the dealer. Now im being told still on backorder no idea when part will be received. This causes a problem for me if I can't really use this car because of the safety risk this may result in extended brake pedal travel required to stop the vehicle, increasing the risk of a crash. There are no warning lights yet displayed.

Tl the contact owns a 2008 Mercury Milan. The contact received notification of NHTSA campaign number: 19v904000 (service brakes, hydraulic) however, the part to do the recall repair was unavailable. Steven's 112 Ford (507 NY-112, east patchogue, NY 11772) was contacted and it was confirmed that the part was not yet available. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue and referred the contact to a local dealer. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact owns a 2008 Mercury Milan. The contact stated while driving 15 mph and approaching a traffic light, when depressing the brake pedal to the floor but failed to stop. The contact stated no warning light was illuminated. The contact stated he crashed into the curb and bent the front passenger side rim which blow out the tire . The contact stated the vehicle came to a stop. The air bags did not deploy. The contact stated he sustain injuries on both knees and his chest. The contact did not seek medical attention. A police report was not filed. The vehicle was not drivable. The contact uncle towed the vehicle to the uncle's residence. The contact was able to replaced both front driver and passenger tires, the front passenger side rim and the "motormouth". A dealer was not contacted. The vehicle was not diagnosed. The contact later on received notification of NHTSA campaign number: 19v904000 (service brakes, hydraulic) and NHTSA campaign number: 21v158000 (air bags), however, the part to the recall was unavailable. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The failure mileage was approximately 169,000. VIN tool confirms part not available.

I received a recall notice in January 2000 recall #19s54/NHTSA recall 19-904. I have called numrious times to have this recall corrected on my car and I called again this week January 2001and they still do not have the parts to correct the problem, in think this to long they tell me another 3 months before they can fix the problem. They did tell me they could fix it however I would need to pay for it. I feel waiting a year and 3 months to correct this problem is unheard of. I have over $800. That I have already paid to correct the problem. My brake pedal and gas pedal are the same position and need to be very careful driving this car what eer help you can give me is welcomed paul eschmann 586 293 6394 e mail p. Eschmann@sbcglobal. Net 16390 gordon street fraser, michigan 48026.

For several years I have not been able to trust my brakes. If I hit a bump I will lose my brakes, and have to keep pumping them the get them to stop. If I hit another bump it seems to put them back to normal. However over the course of the last 2 years my brakes have gotten steadily worse. At this point they don't want to stop me at all. 01/19/2021 I almost had a serious accident driving down base (a country road), I was driving around 35 miles an hour but was slowing down because I knew the stop sign was up ahead. I came to the stop sign and had no brakes. A car was coming and I kept pulling the steering wheel to the right and I was finally able to get the car pulled to the side of the road. By a ditch. No one was hurt luckily, but it could have been much worse. My brakes have been recalled since January of 2020 and I have had problems with them since 2017. But no one could figure out what was going on. I do have the documention from don meyer Ford showing where I took my brakes in explaining that my brakes were bad. They explained to me the cost of getting new brakes but also told me that I would have to pay and then I may get reimbursed or I may not. I don't have that kind of money to pay for new brakes at this time. Not only do I drive this car back and forth to work I raise my granddaughter who also rides in this car with me. Please see attached invoice from where I had my brakes checked, also first recall date Jan 2020 and second recall dated oct 2020. .

For several years, I have not been able to trust my brakes. If I hit a bump I will lose my brakes, and have to keep pumping them the get them to stop. If I hit another bump, it seems to put them back to normal. However, over the course of the last 2 years my brakes have gotten steadily worse. At this point, they do not want to stop me at all. 01/19/2021 I almost had a serious accident driving down base (a country road), I was driving around 35 miles an hour but was slowing down because I knew the stop sign was up ahead. I came to the stop sign and had no brakes. A car was coming and I kept pulling the steering wheel to the right and I was finally able to get the car pulled to the side of the road. By a ditch. No one was hurt luckily, but it could have been much worse. My brakes have been recalled, since January of 2020 and I have had problems with them since 2017. But no one could figure out what was going on. I do have the documentation from don meyer Ford showing where I took my brakes in explaining that my brakes were bad. They explained to me the cost of getting new brakes but also told me that I would have to pay and then I may get reimbursed or I may not. I do not have that kind of money to pay for new brakes at this time. Not only do I drive this car back and forth to work, I raise my granddaughter who also rides in this car with me. Please see attached invoice from where I had my brakes checked, also first recall date Jan 2020 and second recall dated oct 2020. I do have a case # that I filed with Ford motor company it is cas-283-77206 and I talked to ron. I called to see if I replaced the brakes would I be reimbursed, and was told probably not. This is my only mode of transportation. Any help would be greatly appreciated. I am also attaching the service billing from where I first told them about my brakes and both recalls.

As I was driving my vehicle, there will constantly be a loss of braking pressure in the brake pedal during my daily travels. At times I would hear the air huff as I broke into slowing down my vehicle or having to make a complete stop I would have to switch lanes to decrease my speed if possible or begin to break serval cars away to come to a complete stop because there was a lack of brake pressure . I was only informed of this recall last year in November after driving the vehicle for serval months. After months of contacting serval dealerships and consistently being told that the part was not available. Or being directed to the manufacturer for answers to still to be told to contact the dealers again to no avail there was still no parts made available. It has been a constant worry on the safety of my life and those who enter my vehicle. There has only been one moment while driving my vehicle where I felt immediate danger. While driving on the highway when traffic came to an abrupt stop and the only way I did not crash my vehicle going at 45 mph was by swerving into the next lane to slow down. This should not be a continuous issue when the safety of not only myself but other drives on the road at at stake.

The contact owns a 2008 Mercury Milan. The contact stated that he had initially received a recall notice for NHTSA campaign number: 17v024000 (air bags) and had the vehicle serviced at a dealer. Despite the recall repair, the passenger’s and driver’s side air bag warning lights illuminated. The contact also stated that the abs warning light was also illuminated on the instrument panel. The contact had yet to experience a brake failure despite the warning light. The contact received notification of NHTSA campaign number: 21v158000 (air bags) and 19v904000 (service brakes, hydraulic) however, the parts for the recall repairs were unavailable. The manufacturer had been notified of the issue. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The failure mileage was approximately 139,000. VIN tool confirms parts not available.

I received a safety recall notice (19s54) in January 2020 for my 2008 Mercury Milan. This notice indicated a potential issue with the brakes on my vehicle. I am experiencing a problem exactly like what is described in the notice, and have been having this issue for a long time (years). The official notice from Ford/Lincoln indicates "parts are anticipated to be available late first quarter 2020. " we are well beyond the end of first quarter 2020, and I have heard nothing further regarding the issue. Our family is less than comfortable continuing to drive the vehicle, so this information is sorely needed. It also reduces the value of my vehicle to have an outstanding recall with no known remedy in sight. I would request NHTSA intervene and require Ford/Lincoln/Mercury to provide, at a minimum, an update to customers. If Ford is able to continue producing new vehicles and selling them, that is clear evidence that the covid-19 pandemic is not a valid excuse for no action on this issue.

Tl- the contact owns a 2008 Mercury Milan. The contact stated that the daughter was driving approximately 35 mph and the brakes malfunctioned when pressing the brake pedal causing the driver to loose control of the vehicle and crash into a guard rail. During the crash no injuries were reported. No police report was taken and the vehcile was not towed. The vehicel was taken to the local dealer lithia Ford located at 501 mary jane wood circle, morgantown, wv 2650 who was unable to duplicate the failure and no service was performed. The manufacturer was notified of the failure. The contact indicated that the vehicle was included in the NHTSA campaign number19v904000 (braking system) but the parts needed to repair the defect was not availible. The contact also indicated that the vehicle had experienced the same failure listed in the recall on multiple occasions. The failure mileage was 75,000. Jft.

Tl the contact owns a 2008 Mercury Milan. The contact received notification of NHTSA campaign number: 19v904000 (service brakes, hydraulic) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. Levittown Ford, llc (3195 hempstead turnpike, levittown, NY 11756, (855) 346-3558) was contacted and confirmed that parts were not yet available. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

I have had the brakes repaired on my daughter's car twice in one year. She can no longer drive the car because the brakes are so bad. The recall was almost a year (Dec 2019) ago and I'm still waiting on this part. We haven't been able to drive this car since 08/2020 due to the difficulty with stopping. Now inspection is due and I still can not get the brakes fixed in order to get the car inspected and pay for the taxes/registration. What do I do?.

The recall 19v904 has been unresolved now for 16 months. My brake pedal must be pushed all the way to the floor to stop the vehicle. My tags have been expired for 11 months because I can't pass an inspection. I have no other option but to drive the vehicle to work and now I'm paying tickets for expired tags. Ford is worthless to speak to about it.

The contact owns a 2008 Mercury Milan. The contact received notification of NHTSA campaign number: 19v904000 (service brakes, hydraulic) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. Sunrise Ford (5435 us-1, fort pierce, FL 34982) was contacted and confirmed the part was not available for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

Hydraulic control unit of the anti-lock braking system is not working correctly.

Tl the contact owns a 2008 Mercury Milan. The contact stated that that while driving at an undisclosed speed, the vehicle loss braking function without warning. The failure recurred five times. The vehicle was taken to an independent mechanic who stated that the vehicle was included in NHTSA campaign number: 19v904000 (service brakes, hydraulic) and referred the contact to the dealer. The vehicle was taken to fred beans Ford located at 1939 Lincoln hwy, langhorne, PA 19047, where the dealer confirmed that the vehicle was included in the recall. The contact was informed by the technician that as per the manufacturer, the part was not available. It was suggested by the technician to the contact, to pay for the part and to be reimbursed in six to eight weeks for the repair. The contact stated that she could not afford to pay. The vehicle was not repaired. The failure mileage was approximately 120,000.

The contact owns a 2008 Mercury Milan. The contact received notification of NHTSA campaign number: 19v904000 (service brakes, hydraulic) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. All american Ford in point pleasant (3306 bridge Ave, point pleasant, NJ 08742) was contacted and confirmed that the part was not yet available. The contact had experienced the failure listed in the recall. The manufacturer was made aware of the failure. The failure mileage was 70,000. VIN tool confirms parts not available.

I received a letter from Ford on 1/31/20, informing me that my model car has a safety recall because a valve in the hydraulic control unit of the anti-lock braking system may be stuck open. On 8/10, I called the Ford dealership in my area and was told that the parts to correct the problem were not yet available. I'm greatly concerned about the safety of driving my car under these conditions. Isn't 7 mos. Long enough for Ford to have come up with the necessary parts?.

Rec letter January 2020 for vehicle, a valve in the hydraulic control unit of the anti lock braking system may be stuck open increasing the risk of a crash. I am afraid to drive the vehicle. I am requesting a rental since it has been over 6 months since I have driven my vehicle.

My vehicle has been the subject of two recalls with no action on the part of the manufacturer to fix the problems. On 1/21/20 I took the vehicle in to the dealer, hertrich capitol, 1127 south dupont highway, dover, DE, because the brake pedal was soft. I was charged $58 for a brake inspection and was told they could not duplicate the problem. No mention of the recall or a fix was mentioned. Two recalls on this vehicle, for airbag and brake problems have been left unresolved for years. I am the original owner of this vehicle purchased at this location.

Brakes suddenly softened after sliding on icy roads. Fits description of January 2020 recall on this vehicle. Days later, brake pedal continues to travel near floor when braking.

2008 Ford Milan. Consumer writes in regards to safety recall related to brakes on vehicle. The consumer stated the manufacturer exceeded a reasonable amount of time discovering a fix for the recall repair.

The contact owns a 2008 Mercury Milan. The contact received notification of NHTSA campaign numbers: 19v904000 (service brakes, hydraulic) and 21v158000 (air bags) however, the parts to do the recall repairs were unavailable. Keller Ford inc. , located at 3385 alpine Ave NW, grand rapids, mi 49544 and the manufacturer were contact and confirmed that the parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact had not experienced a failure. VIN tool confirms parts not available.