Nine problems related to electric power assist steering system have been reported for the 2005 Saturn ION. The most recently reported issues are listed below.
I have a Saturn Ion 05 and have had to replace the power steering once already and now having the same issue again. Also the turn signal on the front drivers side only works when my hazards or head lamps are on have tested all fuses and replaced bulb twice this is a commom complaint why isnt it being fixed?.
Electrical power assist systems fails while driving both at highway and rural road speeds. Driver has to pull of to the side of the road and restart the vehicle. Same eps on the NHTSA campaign number 10v073000 currently under recall.
The contact owns a 2005 Saturn Ion. While driving at 65 mph, the power steering light illuminated and the power steering malfunctioned. The contact shut off the vehicle and upon restart, the vehicle functioned properly. However, the failure occurred moments later. The vehicle was taken to a local mechanic who stated that the power steering motor failed. The vehicle had not been repaired at the time of the complaint. The current and failure mileages were approximately 92,000. Updated 11/05/10 updated 11/05/jb.
The contact owns a 2005 Saturn Ion. The contact was driving approximately 55 mph when the power steering failed and the steering wheel became difficult to control. A chiming noise was inside of the vehicle prior to the power steering warning light illuminating. The dealer was notified and stated that the failure was identical to the recall on the 2006 Chevrolet cobalt for the electric power steering assist system. The contact was concerned about the safety risk involved. The failure mileage and current mileages were 37,607.
The contact owns a 2005 Saturn Ion. The contact stated that the power steering light illuminated, followed by a chime and a loss of power steering. The contact stated that in warm weather, the power steering failed more frequently. The dealer inspected the vehicle and stated that the electric power steering module was defective. The VIN was unavailable at the time of the complaint. The failure mileage was approximately 96,000. The current mileage was approximately 98,000.
2005 Saturn. Consumer states while traveling down the road unexpectedly the power steering would shut off. The consumer stated the problem was with the power steering assist motor and there was a recall for other models. The consumer stated his vehicle and the other models share the same part number, which would explain why experienced the same problem. The consumer stated the problem is extremely serious, because it is difficult to steer in manual mode with no power steering.
The contact owns a 2005 Saturn Ion. The contact stated that while driving at 55 mph when changing lanes ,the power steering light illuminated and the power steering locked up. He pulled over to the side of the road and turned the vehicle off and then on. The vehicle then drove normally. The vehicle was taken to the dealer where he purchased it, and they stated that it was the steering mechanism that over heats and shuts off. There were no repairs done to the vehicle. The contact stated that this occurs every time he drives the vehicle. The failure mileage was 35000 and current mileage was 36000. Updated 04/01/10. The consumer stated the power steering failed when the vehicle was driven for a long period of time. Updated 06/10/jb.
The power steering on my 2005 Saturn Ion completely stopped working right at about 37000, right after the warranty expired. I tried to have it fixed, but it's a new technology Saturn implemented, (state of the art electronic power steering system), and it will cost $1100 to fix it. My car is fairly new still, and Saturn corp. Refuses to meet with me in the middle on the cost. Without power steering, my car is unsafe to drive, and driving to work and back is a real challenge, and a dangerous challenge, but I cannot afford the cost of fixing it. ***Saturn service advisor admitted to me that lots of the Ions are having this problem. ***.
Power steering failed.