Door Hinge Problems of Chevrolet Express

The contact owns a 2003 Chevrolet Express. The contact stated that the cable that held the seat belts together, located in the rear middle row, snapped without warning. As a result, the contact was concerned that, in the event of a crash, the seat belts would not secure properly and cause an injury. The contact also stated that the rear driver and passenger side door hinges fractured. The contact stated that the doors were glued shut. The dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failures. The failure mileage was 228,000.

See all problems of the 2003 Chevrolet Express 🔎.

The contact owns a 2000 Chevrolet Express 1500. The contact stated that the hinges failed on the cargo side door. It is a double door and only one hinge is supporting the door. He stated that the other half of the door could loosen and fall off while driving, thus causing a crash. The manufacturer stated that there was no defect; therefore, nothing could be done. The contact would be responsible for the repair costs because there is no recall for the hinges. He was informed that the age of the vehicle could have led to the failure as well. The failure mileage was 115,000.

See all problems of the 2000 Chevrolet Express 🔎.

One of the hinges to the double side doors on the full size 2002 Chevrolet Express broke off today.

See all problems of the 2002 Chevrolet Express 🔎.

Dt:consumer bought vehicle new. Afterwards, consumer started having problem with the door handles which broke off. Consumer bought another van, later and the handles were the same. The van just purchased had the same problem. Each time consumer had handles replaced. Consumer pays about $160 per door. Consumer contacted general motors a few times, but general motors refused to answer to consumer's satisfaction.

See all problems of the 2001 Chevrolet Express 🔎.

Recently purchased 2000, Chevrolet Express which exhibited a door problem. The door is loose. After inspection of the side door there is evidence of poor welding. The weld is still partly intact , and the other half is loose. The two door assemblies are very loose due to the poor welding. No repairs have been made.

Passenger doors hinges are sticking.

See all problems of the 1999 Chevrolet Express 🔎.

The contact owns a 1999 Chevrolet Express 3500 van. The hinge on the double doors on the side froze, they will not open anymore. Previously, they where hard to open, and now they are cracking. The dealership said this was bad design. Also, dealership told her that there was back order on the hinges. Obviously a lot of people were having similar problems. The consumer ran a day care center. It was difficult for children to go from the front of the van to the back. In an emergency it would be impossible to get the children out of the van fast enough.

Vehicle's door hinge is broken and inoperable. The consumer had taken the vehicle to two different Chevrolet dealers while the vehicle was under it's original warranty. The side door hinge was broken and not operable. (g 1500).

Hinges on rear side door sticks. Bad design. Unable to grease thoroughly. I can only imagine that somewhere down the road this will lock and the hinge will detach from the side of the van. This is the second of the two side doors the one closer to the rear of the van.

Side door hinges are stiffing up. Tried oiling numerous times. Door is very hard to open and close. If something would happen my younger kids will not be abel to push door open.

The door hinges froze up after a period of time. The consumer had to use excessive force to close the door which caused the door to be misaligned. Ph.

See all problems of the 1998 Chevrolet Express 🔎.

The side door did not unlock from inside or outside due to damaged hinge.

While loading vehicle through the side dual doors lower hinge broke in two. Door will shut. However, does not feel door is properly secured.