Wiring problems of the 2005 Dodge Grand Caravan

11 problems related to wiring have been reported for the 2005 Dodge Grand Caravan. The most recently reported issues are listed below. Please also check out the statistics and reliability analysis of the 2005 Dodge Grand Caravan based on all problems reported for the 2005 Grand Caravan.

1 Wiring problem

Failure Date: 09/04/2018

While at a stop light, another driver told us the van's tail light was smoking. We pulled around a corner and into a parking lot and found that the passenger tail light assembly was on fire with flames lapping up the side of the van. The van was turned off and the fire was extinguished. We removed the tail light assembly and found that the inside of the assembly and the wiring harness were destroyed. There is also body damage. We have had problems with the brake light bulb in the passenger side burning out frequently, and had seen evidence of overheating and some melting in the brake light connector socket in about 2010. Although the lights burn out frequently, the melting had not gotten worse since then. The driver's side tail light has never exhibited a problem like this. At this time it is unknown if there is any damage or fault in the electrical system beyond the tail light assembly. A rough estimate of obvious damages is approximately $1,000 to $1,500 with repainting.

2 Wiring problem

Failure Date: 06/24/2017

The wiring inside of the power sliding door caught fire with out being used. It was the door on the drivers side. The vehicle had just been driven and parked for approx 10 min when the fire was noticed due to the smell.

3 Wiring problem

Failure Date: 07/06/2014

I activated the passenger side automatic sliding door. There was a pop and a flash indicative of an electrical short and the door no longer opened or closed automatically. I inspected the wires and found that two wires were broken and possibly made contact with each other, causing an electrical short. The vehicle was inside my garage at the time and no one was inside. However, this is a dangerous situation should the vehicle catch fire because of the flimsy wiring on the doors. The driver side door stopped working two days later, but with no pop or flash. I noticed several other vehicles had the same problem, and there are several documented cases of the same problem throughout the web.

4 Wiring problem

Failure Date: 02/28/2014

While attempting to operate the electric sliding side door, a large spark and small debris fire was seen in the bottom door rail. Upon inspection, a break in the wire harness had aloud wires to be severed that controls the door and locking system. The automatic door locks on both side doors no longer worked and the passenger side door would no longer open electrically. I removed the wiring harness and wires and discarded them to avoid any more problems (sparking and/or fires). This could cause a major fire hazard in the right environment.

5 Wiring problem

Failure Date: 05/04/2012

The vehicle is not properly sealed. The grounds were all corroded and letting moisture or salt into components. First thing that happened was all the lights came on and then all went out. Couldn't see speed or gears. I have had to replace the basic control module and having the body control module checked out today. Everything under the hood is corroding at a fast pace. You can see even the metal on the engine. I hoping my wiring harness is ok. But the tech hasn't gotten that far yet.

6 Wiring problem

Failure Date: 05/25/2011

The passenger side rear door malfunctions while opening using the power open option. It opens part way and then stops or closes again. The driver side does not open at all using the power open option, only by opening manually. I am concerned for the safety of rear passengers entering/exiting the van and being struck/trapped by the door when it changes directions. It is caused by a short in the wiring harness that powers the doors which could potentially cause a fire.

7 Wiring problem

Failure Date: 03/14/2011

I found on the internet that a bought 63 complaints about the power sliding doors on my 05 Dodge Grand Caravan well I hate to be 64 but I was led to the problem in side the wiring harness there is a red and black wire the door will stop working when the wire breaks and gets exposed there are a lot of complaints that these wires need to be fixed.

8 Wiring problem

Failure Date: 07/16/2010

Problem Dodge Grand Caravan handicap conversion van:on a Friday afternoon 2010 this van stopped in a moving lane NY thruway outside of the buffalo area. Traffic was bumper to bumper,stop and go with many heavy trucks. After 2 911 calls, the thruway flatbed tow truck did not reach us for nearly a half hour. No cops came at all. My husband, in his large motorized wheelchair, and I (the driver) were stopped with traffic moving in the 2 lanes from behind us. My blinkers were on but traffic had to realize we were totally stopped and then useother lanes, including the breakdown lane to our right, to go around us! thankfully,we were not hit by these gigantic trucks. We are alive to tell the story. It is now 10 days later. The first repair shop and then,the next day till now, a dealer repair shop have worked on the van. Two sensors were replaced and then the entire computer was replaced. Both repairs did not make the van start. The dealer shop was in contact with the Chrysler/Dodge corporation. The wiring harness was opened. Part of the problem was found. I don't know all the details of their investigation. Waiting for my vehicle to be fixed, my handicapped husband and I have now amassed $1000 in hotel/etc. Bills due to this incident. And, this cost does not yet include fixing our vehicle. Finally, the dealer repair shop arranged to have a rental van delivered to our hotel (our cost) so we could finally get the special wheel chair and drive home 8 hours. And thus far all the costs are mine. I now have another $1000 rental fee facing me because the wheelchair van to get was rented for 8 days, on the dealer repair shops arrangements. A fee would be charged for "early" return of the wheelchair rental. Note that my husband had only a borrowed manual, non-tilting wheelchair for the duration. Please help us sort this out and save others from the stress and fees we have endured for this. I am now also afraid to drive that Dodge van back home on a busy highway, or anywhere.

9 Wiring problem

Failure Date: 07/15/2008

2005 Dodge Grand Caravan power sliding door failure due to faulty wiring harnesses. This has occurred for the past two years. The wiring harness has broken wire internally and then the door will not function or will partially function. When it partially functions, the driver may begin to operate the vehicle when the rear doors are not completely shut.

10 Wiring problem

Failure Date: 06/01/2007

Have had numerous problems with van starting 3 months after purchase. Dash lights flash but only for seconds so no code can be read. Electric windows failing, batteries replaced numerous times. Have gotten to point I purchase window tracks and replace myself to save on cost. Most recently dash lights and headlights flashing rapidly radio and air go out and vehicle wanting to stall. This is a conversion van by braun. Had handicapped person in wheelchair in passenger side front. Van stalled in intersection but was able to get off to side of road. Where I was, I could not get wheelchair out of van. We could have been killed not to mention I live in florida and heat was at a feel like temp of 108. After 10 or 15 minutes van restarted and was able to limp home. Auto electric repair shop replaced ignition wiring harness but after 30 days it is now doing same again only worse. I now have no transport for handicapped person because why fix something that cannot be resolved without changing every part to figure out real problem. I know even if the bcm is replaced that is only temporary according to other reports of same problem I have.

11 Wiring problem

Failure Date: 10/04/2006

Dear sirs: 2005 Dodge Grand Caravan se . It has had numerous problems, few of which were fixed properly when brought back to the dealership. Finally, on October 04, 2006, with 29000+ miles on the vehicle, an axle broke as my son, daughter-in-law, and two grandchildren under two years old pulled out of a parking lot onto the road. Had this happened on an interstate, with the vehicle moving at a high rate of speed, there is every likelihood that a fatal accident would have occurred. Axles do not break except under extreme circumstances or when there is some fatal fault with the manufacture itself. This is not a vehicle which has been abused. It has been used to transport housewives and small children back and forth to school, to grocery, etcetera. It has been serviced at all proper intervals at the mechanicsville, va dealership where it was purchased. Except to move the vehicle so as to avoid storage charges, I will not have any member of my family transported in this vehicle. The service department at mechanicsville Dodge claims to have repaired the vehicle and that it is safe. They have all ã‚ã‚⦠driven it and it drives fine!ã‚쳜 that is illogical for a number of reasons. First, it ã‚drove fineã‚쳜 right up until the moment the axle broke, even though numerous electrical and other problems existed which were not fully repaired at that time. Second, I have absolutely no reason, based on my past experiences with shoddy work and outright falsehoods at this store, to believe that this shop is capable of properly repairing the vehicle. Third, there is no reason to believe that other life threatening problems do not exist, lurking in this vehicle to strike my family if we were to trust it or mechanicsville Dodge once again with our lives.



Safety Ratings of Grand Caravan Cars
Fuel Economy of Grand Caravan Vehicles
Grand Caravan Service Bulletins
Grand Caravan Safety Recalls
Grand Caravan Defect Investigations