Two problems related to steering rack and pinion have been reported for the 2016 Ford Edge. The most recently reported issues are listed below. Please also check out the statistics and reliability analysis of the 2016 Ford Edge based on all problems reported for the 2016 Edge.
The adaptive steering module integrated in the rack and pinion shorted and one can no longer use the adaptive steering feature. The NHTSA recalled the steering wheel with the electric adaptive steering motor, however NHTSA did not recall the rack and pinion with the defective adaptive electronics. I'm lucky my steering wheel failed straight and did not cause the steering wheel to be cocked. I would like to prevent car manufacturers from integrating electronics into non-serviceable components. The only way to resolve the adaptive steering failure is to replace the rack and pinion. Going forward all automotive manufactures should not be allowed to integrate non-serviceable electronics with mechanical parts. The vehicle was stationary and I tried to modify the settings for the adaptive steering in driver assist settings. The adaptive steering feature is no longer available since the electronics shorted. Why recall the steering wheel and not the electronics in the rack and pinion. It does not add up because it was an 50% repair. Why bother with the recall if you did not address the entire problem. The adaptive steering electrical components in the rack should be a removable module so you can repair the electronics without having the change the entire rack and pinion.
Got codes for no steering assist fault and no advance trac, meaning no power steering and no awd. There are recalls for this but was told, my car didn't apply because not made at the plants they were made. Took my car to a Ford dealership, had them look at it, after disconnecting battery for 10 minutes, both came back, but said rack and pinion was bad? my car just past the 36,000 miles in garage miles were 38804. This car only drives on paved roads, not all new paved but good roads. 'how can this be part be bad with just 2000 miles over coverage? why is it bad at this mileage? not happy to have to pay $2600. 00 to replace at such low millage? something was bad with this part from the start!!! if I have to replace this part and not covered by Ford plus my cost to I paid to have them lok at it. I will never buy another Ford, built tough my ass!!! plants.