Auxillary Tank Selector Device problems of the 1996 Ford F-150

13 problems related to auxillary tank selector device have been reported for the 1996 Ford F-150. The most recently reported issues are listed below.

1 Auxillary Tank Selector Device problem

Failure Date: 07/01/2005

The contact owns a 1996 Ford f150. The contact stated the vehicle has a duel gasoline tank. When the back tank is selected it will pump gasoline to the engine, but it will also pump gasoline into the front tank and pressurize the gasoline, forcing it out of the filler neck and cap. When the vehicle is parked gasoline overflows onto the ground, and when driving the vehicle, the gasoline spills out along the highway. When the cap is removed from the tank, a larger amount of gasoline will spill out, and the gasoline is filled up to the filler neck. The consumer has to watch the amount of gasoline that is in the back tank to ensure that the overflow will not occur. The service dealer said that the check valve had to be replaced. The check valve prevented the gasoline from going from the back tank into the front tank. The manufacturer said they would not cover the cost for the repair. Updated 01/04/06.

2 Auxillary Tank Selector Device problem

Failure Date: 09/22/2004

Fuel leaks from the front tank vent cap down the vehicle side to the ground. Occurs regularly when both tanks are filled and rear tank is used first. Have to switch between tanks frequently to keep contents from overflowing. This is a known problem. Not enough people dead yet? recall it.

3 Auxillary Tank Selector Device problem

Failure Date: 03/10/2004

Fuel is transfering to front tank when using rear tank causing fuel overflow onto ground and poor idling when front tank gets pressurized.

4 Auxillary Tank Selector Device problem

Failure Date: 03/01/2002

When switching to front tank it started to build pressure, and gas pour out of rear tank filler spout. Please provide any further information.

5 Auxillary Tank Selector Device problem

Failure Date: 02/01/2002

While fueling rear tank front tank started to overflow. Vehicle has not been taken to dealership.

6 Auxillary Tank Selector Device problem

Failure Date: 07/13/2001

93 v 125 000/fuel tank assembly: a portion of unused fuel from one tank to be returned to second tank. When it occurred the second tank exceeded, causing fuel spillages. Spill can result in a fire when exposed to a source of ignition. Dealer/manufacturer were notified, and informed consumer that vehicle was not covered under recall.

7 Auxillary Tank Selector Device problem

Failure Date: 02/10/2001

Problem lies with back fuel tank; when it pumps fuel to front tank there is too much pressure, fuel drips to ground. Also had to replace cracked torque converter.

8 Auxillary Tank Selector Device problem

Failure Date: 01/06/2001

When pumping fuel into one of dual fuel tanks, one tank overflows into another tank that's already full, causing a fuel spillage.

9 Auxillary Tank Selector Device problem

Failure Date: 01/25/2000

Fuel from the rear tank flows into the front tank, through the fuel system.

10 Auxillary Tank Selector Device problem

Failure Date: 12/17/1999

The truck is equipped with dual fuel tanks. When both tanks are filled and the rear tank is selected it pumps gas into the already full front tank, causing it to run out of the fuel cap down the side of the truck onto the ground. I feel this could easily cause a fire yet have been unable to get the Ford dealer to repair this problem. I have not been able to use the rear tank for over two years. Is this a common problem with dual tank Ford trucks?.

11 Auxillary Tank Selector Device problem

A portion of unused fuel from one tank is being returned to second tank, causing fuel leakage. Dealer has been notified. Please provide further information.

12 Auxillary Tank Selector Device problem

A malfunction within the check valve and fuel pump assembly causes a portion of unused fuel to transfer from one tank to the second tank, causing fuel leakage. Vehicle was not included in recall 93v125000/ fuel tank: auxillary selector and switch. Please give any further details.

13 Auxillary Tank Selector Device problem

Rear tank was pumping fuel into the other tank, causing it to overflow and leak gas. Dealer has replaced fuel pump and check valves.



F-150 Service Bulletins
F-150 Safety Recalls
F-150 Defect Investigations