One problem related to engine cooling system has been reported for the 2005 Ford F-250. The most recently reported issues are listed below.
The contact owns a 2005 Ford F-250 superduty. While driving approximately 45 mph, thick smoke appeared from the rear exhaust pipe. The vehicle began stalling while en route to an authorized dealer. There were no warning indicators prior to this failure. The vehicle was taken to the authorized dealer. The mechanic replaced the 2, 6, and 8 fuel injector components; however, the failure continued. The vehicle was taken to the dealer two additional times, but the failure was not corrected. The first repair was covered under warranty at the cost of $106. 50. The total repair cost was $506. 70. Most recently, the vehicle was taken to an independent mechanic, who stated that the previous failures were related to the egr cooler system. The vehicle has not been repaired. The failure mileage was 95,246 and current mileage was 120,000.