Power Steering Fluid Problems of Ford F-450

Entered on 10/04/2016 at 2:45:07 pm edt (gmt-0400) by NHTSA. Webmaster@dot. Gov:  sender name: sender email: subject: Ford F-450 cooling system failure and engine problems comments: I purchased this truck new in 2008 and drove it cross country towing my 5th wheel. At 4,544 miles the radiator blew apart. (driving highway/towing) this was replaced under warranty after fighting with Ford. At 6,065 miles I had another cooling system leak. (driving local) they had to replace the "small" radiator, the "fuel and turbo" cooler. At 21432 miles the power steering pump went and had to be replaced. (driving/towing/local) shop stated that "fluid was contaminated" (this truck has only been serviced by Ford) at 22215 miles I had to have the left rear axle seal, brake pads and lower cac hose for turbo replaced. ( driving highway/towing) now at 29,017 miles the radiator tanks have separated from the core and need to be replaced again along with the crank seal and another power steering pump. ( combination, highway/local/towing? not towing) I have checked with Ford and their customer service department and they refuse to cover any of this, or any part, under warranty. I have also done research on these trucks having found many other owners having the same cooling system issues along with other issues that Ford refused to cover. Please look into this issue, I think they need to have a recall on the cooling systems in their trucks. Thank you for taking the time to read this. I would appreciate a response. Check edmunds Ford F-450 sd turbo diesel review, multiple complaints of cooling system failure, engine failure.

See all problems of the 2008 Ford F-450 🔎.