One problem related to automatic transmission cooler has been reported for the 2007 Ford Fusion. The most recently reported issues are listed below. Please also check out the statistics and reliability analysis of the 2007 Ford Fusion based on all problems reported for the 2007 Fusion.
Several (all wheel drive )awd Ford vehicles ex. Fusion, edge, taurus use a (power transfer unit) ptu that fmoc call for no service needed, no drain plug only a fill port. The ptu is a basically a transfer case that small Ford Ford awd vehicles use to transfer engine power from the transmission to the rear wheels. The part is connected to the transmission surrounded by the engine, exhaust and catalytic converter, the ptu only hold a quart of lubricating fluid no cooling no service interval and all of the heat surrounding the unit bakes the lubrication causing lack of lubrication causing ptu and transmission failure. Repair quote from a Ford dealership on 1/29/2020 with a Ford remanufactured transmission and labor is $5000. 00 repair. This unit failure is in a 2007 Fusion with 92k miles other than the powertrain issue is a solid vehicle that perform great until the ptu and transmission failure with no warning. While driving at highway speeds the vehicle wheels locked up skidding the car to a stop and stalling the engine. Now it cracks and pops and locks up the wheels.