Ford Fusion Hybrid owners have reported 1 problem related to gas recirculation valve (egr valve) (under the engine and engine cooling category). The most recently reported issues are listed below. Also please check out the statistics and reliability analysis of Ford Fusion Hybrid based on all problems reported for the Fusion Hybrid.
While driving in heavy traffic on a hot (90 degree) day in phoenix az a red triangle warning light came on and said to stop immediately, then the engine quit. I was fortunate to have a place to coast to and stop. I turned off the ignition and re-started the car. It ran fine for a few miles, then it stopped again. When troubleshooting, the code, poa7c came up. (motor electric overtemp) the water pump for cooling the electric drive motor was replaced approximately a year ago because of the same code, but the engine didn't quit at that time. I noticed online that this is a very common and dangerous problem with Ford hybrid cars. I called a Ford dealer, and they told me that there is no recall for this problem on my vehicle.
See
all problems of the 2010 Ford Fusion Hybrid
🔎.
| Problem Category | Number of Problems |
|---|---|
| Engine And Engine Cooling problems | |
| Car Stall problems | |
| Check Engine Light On problems | |
| Engine Shut Off Without Warning problems | |
| Engine Failure problems | |
| Service Engine Light On problems | |
| Loud Engine Noise problems | |
| Manifold/header/muffler/tail Pipe problems | |
| Engine Exhaust System problems | |
| Gas Recirculation Valve (egr Valve) problems |