Table 1 shows one common unknown or other related problems of the 2002 Ford Windstar.
| Problem Category | Number of Problems |
|---|---|
| Unknown Or Other problems |
I was driving my 2002 Ford Windstar at approximately 60mph when it began to shake violently. Suddenly the rear axle snapped. I almost went into a spin but fortunately I was able to keep control of the vehicle and not hit or kill anyone. God was watching. The axle snapped to the left of center just like countless other Windstars that I have read about.
My Windstar went to a Ford dealership a few months ago for the subframe recall and rear axle recall. It was said to be in great condition and fitted with the repair kits. Subsequently, my husband went under the car for unrelated reasons and saw the subframe bracket was not holding anything because the passengers side subframe was rusted away. When he took it to the local dealership the mechanic stated that it should be left with him because it was not safe to drive. My husband requested they remove the back axel bracket which they did only to reveal a crack in the axel. We were told by several employees that it should be replaced. However the dealership contacted Ford di dept who rejected the claim based on the fact that it was poor workmanship of the dealership and the dealership blames Ford. Needless to say they gave me back my car with a rusted subframe and cracked axel stating that it was in fact repaired to Fords standard. My husband has pictures of both the subframe w kit and axel. It is difficult to understand how Ford can deem it safe to drive? in addition to the original recall, I believe Ford is covering up the defect and attempting to get away with putting recall "kits" on cars that may be unsafe. I would like to be sure my car is infact safe.
Front right coil spring broken and left side show fatigue in same area. Vehicle had other recalls due to high-corrosion areas.
The Windstar is my only means of transportation and when driving it the speedometer will freak out and ended up breaking the needle on the tacometer and this leads to the theft light popping up when I am driving down the road. This acted up when I was going over and intersection and ended up stalling the vehicle right in the middle and while a car was coming from one way luckly I got the vehicle started and time and got out of there but after taking it to the dealership they couldnt even figure out what could be wrong I dont feel like loosing my life.
All the time when I'm driving the abs/brake light stays on, the vehicle does not stop properly. The #10 and 15 fuse blows out regularly and causes the air, odometer, overdrive to not work. I smell burning electricity, and see smoke coming from hood while driving. Some morning my van doesn't start due to battery drainage. Check engine light will not stay off causing it not pass inspection. Brake fluid leaking. I truly believe that the break fluid leak is causing these problems, and it looks like I'm not the only person. With the speed control recall the abs module and ecm needed to be included.
While driving we noticed a loud popping sound and the car pulled to the side. We stopped at a firestone and they showed me that the subframe had rusted through on the passenger side and the motor mount was completely broken loose. They recommended that we go to Ford. We took it to the Ford dealer and they said they knew of the problem but our minivan was not included in the recall because it is here in florida. I have serious problems with my spine and the doctor told me that a small accident could be fatal. I called the number Ford service manager gave me. Ford refused to help. Even though the subframe corroded and broke on the passenger side as was the concern with recalled vans, they flatly refused to do anything -- not even provide a discount on labor! since this car is here in florida, it is very obvious that the corrosion must have been caused by a defect in manufacture. I need the van to get to physical therapy and to take care of my family. It is not just that I should pay the $1700-$1800 that Ford estimates will be the cost to fix their error and am left without transportation. If I had not noticed the popping sound, I could have had a serious accident and been dead or paralyzed from my neck down!.
Ford motor CO. Recall #10s13 NHTSA #10v385000 recall inspection performed at casco bay Ford yarmouth maine 04096 on 10/01/10. No cracks found. Technician removed large areas of paint from rear axle. Maine winter weather. Unpainted rear axle has rusted badly since inspection. Ford motor CO. Has assigned case #0333002594.
About 2 years ago I have noticed that the abs and brake light would come on sometimes now after driving a few miles they come on constantly now. I spoke to a Ford service advisor and was told it would cost me over $600. 00 to repair and that there was a recall only for certain states. This does not seem fair to other Ford owners to have to pay for something that Ford has a default on and seems to be a problem with in a lot of these vehicles. I can not afford this repair and I'm sure most people can not afford. Please look into this. ## VIN passed ## Ford, Windstar lx, 2002 ##.
My passenger side rear brake pads wear out - down to bare metal each year and I keep asking that they look into it being something other than my braking habits because it is only one brake. I just saw on the news that the rear axle's on my particular make and model are breaking and there is supposed to be a recall. I drive through rural areas long distance and I am very concerned for my safety. I wonder if there may be a connection between the faulty axle and my brake not fitting right and wearing out every year. Now I have a strange sound coming from the back of my van either the middle or passenger side and I am afraid I will suffer a terrible accident. I have been unemployed over 2 years because I couldn't get a job while in college and graduated in a recession. . . . I have no credit cards and can't afford the mechanic's charge to inspect it or fix it.
Stopped in visitor center in gettysburg,PA. Put van in reverse and it locked up. Looked under van and noticed rear axle broke in half. Had to tow it home and had local Ford dealership install new axle at my expense.
I own a 2002 Ford Windstar. I bought the vehicle new in 2002. It currently only has only 75,398 miles. Approximately, 1 week age my wife drove my son to his soccer and baseball practice. While she was driving home with my 2 other sons in the van, she noticed that there was suddenly a problem with the back wheels. Luckily, she made it home without any injuries. After she parked the van, she noticed that the wheels were smoking and were slightly turned in. I had it towed to our mechanic. A few days later, the mechanic called and stated that the rear axel was cracked. He said that he never seen anything like it, especially on a vehicle with only 75, 398 mile. He said that he was going to call around and try to find a used part. After a week (of not having a vehicle), the mechanic called and stated that he called everywhere for a used part. However, he was not successful in locating the part. Once again, he stated that he never experienced not being able to locate a part. He said that it was probably due to the fact that so many other vehicles had the same problem. He said that he could put a new part on, but it would cost approximately $1,000. I called the dealer where I purchased the van and they stated that since the warranty has expired, there is nothing they could do for me. After doing research and trying to find a used part on my own, I have noticed that I am not alone with this problem. In fact, there is a class action law suit filed against Ford motor company. I think that this matter could easily be resolved if Ford were required to have a recall to rectify the problem. I realize that I am only 1 of a few thousand that have made this problem known. However, I wonder how many Ford Windstar owners who have not experienced this problem yet or who have elected to do nothing about it. It make me very furious to know that this problem exists and was made aware of, and nothing is being done about it. How many lives will it cost before something is done?.
Abs brake light comes on all the time when I'm driving the 2002 Ford Windstar sel. It started last year. I've replaced all the pads & shoes and bled the brake fluid. But it's still on. I've read many complaints about this online and wanted to add my complaint to the list hoping for a Ford recall.
Orange abs and red brake light on while driving 02 Ford Windstar le. . Read more...