Five problems related to other fuel system pump have been reported for the 2011 Jeep Wrangler. The most recently reported issues are listed below.
When filling up at a fuel pump, the fuel pump handle will click off and after that happens, about 1/4 of a gallon of fuel will spill out of the filler neck onto the side of my vehicle.
2011 Jeep Wrangler is very hard to fuel. When fueling fuel pump continually shuts off. Must reduce to a very slow rate and even then it will sometimes shut off no matter what pump is used. Occurs at every gas station and every pump. So now I have to pump gas into the Jeep really slow been care full as not to have a fuel back splash.
My 2011 Jeep Wrangler has major electrical problems. The windshield wipers wouldn't turn off even after shutting off the engine. I pulled the fuse but they still stayed on. I could smell something electrical burning so I had to disconnect the battery. Also the door locks don't work and front cigarette lighter stopped working. I called the dealer and made an appointment to bring it in. While driving to the dealer the Jeep started to shake horribly when accelerating (due to electrical issues with the fuel pump). The dealer says that I need a new totally integrated power control module (tipm). The cost is well over $1000 (the vehicle is out of warranty). When I searched tipm problems on-line I found that Chrysler has tons of complaints about this but the only issued a recall on a few vehicle models and Wrangler wasn’t included. There are obviously a bigger number of vehicles affected and Chrysler should recall the remaining models.
Around the date listed above, and since then with every fuel fill up, once the fuel nozzle stops filling, the vehicle spills fuel all over the outside of the vehicle and onto the ground, creating a fire hazard. It did not do this when it was new, and it happens at all different fuel pumps and filling stations. There is a recall for similar vehicles, but it does not include this year. I think that it should.
When filling up my Jeep with gas sometimes fuel will spew out even when the fuel pump clicks to stop. It will spew out and go down the side of me Jeep onto the ground. Enough where the attendant needs to be told. This is the same thing that happened on my 2008 Jeep Wrangler as well.