Two problems related to engine stall have been reported for the 2005 Nissan Pathfinder. The most recently reported issues are listed below. Please also check out the statistics and reliability analysis of the 2005 Nissan Pathfinder based on all problems reported for the 2005 Pathfinder.
Nhtsa recall number: opens new window takes away from VIN lookup section> 10v-517 recall date: October 28, 2010 manufacturer recall number: pc068 summary: the intelligent power distribution module (ipdm) assembly contains an engine control module (ecm) relay that has a diode for electrical current noise reduction. The ecm relay may allow silicon vapor to form and, over time, the silicon evaporates from the diode molding which causes silicon oxide to develop on the ecm relay contact due to arcing. Safety risk: this could cause engine stalling increasing the risk of a crash. Remedy: dealers will replace the ecm relay inside the ipdm assembly.
The contact owns a 2005 Nissan Pathfinder. The contact stated there was an abnormal vibration in the vehicle as if he was driving over a severely bumpy road surface. The vehicle was taken to an authorized dealer where the contact was informed that the valve body was the cause of the failure. The vehicle was repaired but the failure persisted. The vehicle was taken back to the dealer where the manufacturer was contacted and stated that the problem was common but would not offer any assistance. The failure progressed to the point where there was a stutter in the engine and the vehicle would stall without warning. The vehicle was not repaired. The failure mileage was approximately 122,000 and the current mileage was approximately 126,000.