Fuel Delivery Problems of Nissan Xterra

After filling the vehicle with fuel the gas gauge failed to properly read the correct amount of fuel in the vehicle after filling the tank all the way the gauge stayed at the half full mark and remained there the vehicle was giving the Nissan technician a code reading of 0463 ( fuel level sensor high input) when I went to the dealer I was told this problem was wide spread with one or two Xterra trucks a day coming in for this problem at this dealer alone I was told today by Nissan customer service Nissan will not have a full recall done for this problem saying it is VIN specific but obviously it is not a VIN specific problem and I asked for reimbursement for the repair but Nissan refused to do anything for me.

See all problems of the 2006 Nissan Xterra 🔎.

Fuel sending unit that was replaced on 4/25/2005 due to recall of possible corrosion failure failed due to corrosion.

See all problems of the 2001 Nissan Xterra 🔎.

Consumer received recall notice 04v230000. Contacted dealership and brought vehicle in for repair. Dealer was refusing to do recall repairs. Dealer indicated to consumer vehicle must be left for undetermined amount of time until mechanic could get to it in order to repair recall. That was an inconvenience to the consumer since no other transport was available.

See all problems of the 2000 Nissan Xterra 🔎.

While driving 5 mph the vehicle stalled. The consumer restarted the vehicle and drove it to the dealer for inspection.

Complaint concerns the fuel tank sending unit. My vehicle went dead on hwy 131s at 6:00 in the morning. Alone and out of town. Had to be towed on flatbed. When talking with the local dealership they stated they have had to replace this part on numerous occasions. I then called my private, usual dealership I have service at and they stated they had replaced three of these in the last month. This needs recalled!!.

My fuel sending unit failed on a dark highway on the evening of Feb 6, 2004. The vehicle is a 2000 Nissan Xterra. While I have never had problems with the vehicle until now- I have found that the fuel sending unit has a flawed design and fails very often, especially in winter climates- the unit is suceptable to road salt that corrodes the electrical connection to the fuel pump- there is really no need for this to cause the truck to shut down. I was left stranded on a dark stretch of road with little breakdown lane room. The tow cost $120 and the parts were $70. If this is a common failure, and I have to believe that it is, based on the numerous cases documented on the internet, then Nissan should have issued a recall as this failure could easily result in injury or worse.

Faulty fuel sending unit. Problem occured during a bad snowstorm. It is known to happen to several Xterra owners I know.

Vehicle stalled while making a left turn from a stop out of a parking lot and would not restart.

Defective fuel sending unit in 2000 Nissan Xterra. Causes engine to cut off while driving.

I am surprised to see only a few complaints on this sight, there's probably thousands that this has happened to. I was driving home one night and the truck stalled out, luckily there was a place to pull over on the side of the road. After I got towed and spoke to Nissan they were ready with the answer - it's the fuel sending unit! a build up of corrosion in the wire of the sending had shorted out the signal to supply gas. Nice job Nissan! piece of crap! recall!!!!!!!!!!!.

April 11th my 2000 Xterra stalled while driving. I restarted it and 5 minutes later it stalled again. The third time it died and wouldn't start again. I had it towed to my house and since it was raining I figured I would try it again in the morning (hopefully whatever was wet would dry out and it would be fine). The next morning it did start and I was able to make it to the highway where it died again (middle lane of a 5 four lane highway!). This time I had it towed to the dealer. I was a little surprised to hear the mechanic tell me what was wrong before he even looked at it (he had a fuel sender unit sitting on his workstation that he had just pulled out of another x with the same problem). Apparently when the x-terra hits 50k to 70k miles the fuel sender units go bad and need to be replaced. The connection for the fuel pump corrodes (green oxide) and also cracks creating an open. The guy working in the parts department said I was lucky because they had just had a run on fuel senders because of this problem and were out for a while but they had just got a new shipment in. I started to feel like this was a known manufacturing defect that Nissan is not letting on to their customers. The clincher was, while I was waiting another flat bed tow truck pulled up with another x-terra. . . That's right, bad fuel sender!! I paid $211. 00 for the fuel sender plus $65 for towing. I checked if others have had this same problem on an x-terra forum web site and it appears to be all too common. Having your motor cut out in the middle of the highway is a very dangerous thing!.