11 problems related to fuel injection have been reported for the 1996 Plymouth Grand Voyager. The most recently reported issues are listed below.
Nhtsa recall 00 v 268 000/manufacturers recall 895 concerning fuel leakage: fuel is leaking from the fuel rail onto the engine. Dealer contacted and informed consumer that vehicle was not covered under that recall due to VIN.
Nhtsa recall 00v268000/ manufacturer's recall recall 895; gas is leaking underneath vehicle in same location for fifth time. Vehicle was recalled and serviced once. Vehicle has never been diagnosed to correct the ongoing problem. Dealer and manufacturer contacted. Please provide more information.
Noticed fuel leaking from fuel tank. After researching internet, etc. Found that there was a recall on the fuel rail. Took to dealer for recall work on fuel rail. Recall work had already been done on o-ring, etc. At dealer, mentioned leaking gas to dealer. Informed that valve is leaking and a new tank would be required. After further research found that this problem exists for many, many others! leak only occurs when tank is at least 3/4 full and van is parked with the front on a downhill angle! Chrysler must know of the problem?.
I had been smelling gas 3 months after purchase. They recalled the o rings and changed that I thought that would releave the problem but it did not. Then in July I was park on a hill and gas started pouring out the tank so I moved the car leveled and it stoped from then on the gas smell was so bad I started having headaches, on August 22, 2001 I took to the dealer and the said it was clapsing and had to be replaced I told them is that the responsiblity of the dealer they said no that it was ware and tear and it would cost 1079. 89. The smell of gas was so bad and I did not think gas tanks just go out from driving! I drive a Mini van w/children in it I do not race this car in order for it to go out!.
No summary listed for abov evehicle.
Vehicle had been included on fuel leakage NHTSA recall 00 v 268 000/ and manufacturer's recall # 895 that stated fuel could leak from underhood fuel injection fuel rail, could result in a vehicle fire.
Consumer smelled a fuel odor. Went to dealer, who stated that he noticed nothing wrong. Consumer then found out about recall on fuel rail. Called Chrysler ,who informed consumer that recall notice would be mailed in July 2001. On Mar 30, 2001 consumer filled fuel tank, and noticed fuel dripping from fuel rail. Had vehicle repaired, Chrysler told consumer they may reimburse her in July.
Over a year and 1/2, had multiple (at least 10) incidents of vehicle stalling while slowing down, at turns or traffic lights. Resulted in loss of power steering, brakes, and temporary loss of control onto next lane; luckily, no accidents. Multiple trips to Plymouth dealership, all inspections and costly empirical repairs are fruitless, until ais (automatic idle speed) motor replaced (throttle body cleaned, also). The mechanic stated he had seen this problem in his own Plymouth! this failure has not recurred in the 3 years since making the ais motor the likely cause of the problem. This is simply a follow-up, hopefully of some use to drivers and mechanics.
Fuel rail is leaking gas onto engine. Dealer has been contacted. There is a recall for problem, but this vehicle is not covered due to VIN. Consumer's vehicle experienced the exact same problem as recall 00v268, however this vehicle was not covered under recall.
Received recall notice #00v268000. Contacted dealership. Was informed no parts were available to repair fuel leakage recall. Service mechanic indicated it was on national back order.
Vehicle was on a slight slope with the front end slopping downward. Noticed fuel leaking onto ground from the area of fuel tank. Had vehicle repaired previously under a recall in oct 2001 for same problem. Had taken vehicle to dealership. Mechanic indicated leakage is from a different location. It's on the intake hose of the fuel tank.