54 problems related to other fuel system have been reported for the 2007 Saturn ION. The most recently reported issues are listed below. Please also check out the statistics and reliability analysis of the 2007 Saturn ION based on all problems reported for the 2007 ION.
My 2007 Saturn Ion recently started leaking drops of gasoline near the driver side rear tire. It is either an issue with the fuel line or the tank. It has not been inspected by the dealership yet. I get a gas cap warning message, but I'm not sure if it is related.
Gas smell when driving and while parked. Mechanic lifted car and saw gas on the top of gas tank, car starting to stall during initial start up.
My gas tank is leaking a good amount of gas and is dripping all over my exhaust. Major fire risk and also my wiring has been all messed up. When my brights are on, my speakers make an unbearable screaming noise and I saw that this was an issue for many Saturn Ion users. There was a recall on this car for the same gas tank/pump issue years ago. Can I get this issue fixed free of charge or has the recall expired?.
It loses alot of gas it leaks all under car and its strong smellimg fire hazard. It does not leak if car is off only when its running. Driving down 75 the under carriage of car soaking wet.
Tl- the contact owns a 2007 Saturn Ion. The contact stated that the fuel line rusted out in two parts. The vehicle was taken to an independent mechanic and was diagnosed that the main fuel line and the fuel vapor line to canister rusted out and had hole. The contact stated that the mechanic replaced fuel line. The vehicle repaired. The manufacturer was made aware of the failure and provided a case number. The failure mileage was approximately was 53,951. Aw.
My cars fuel lines are leaking all over the place while vehicle is running.
I inherited the car from my mother the car has a problem with the fuel system we had it fixed but the same codes are poping up.
Service person says that I need to replace the fuel injector line. Thought that was done so by a recall I had done already. Hard to start and smell of gasoline.
Started smelling gas then noticed a few days later that it was leaking when driving and parked.
Leaking gas and strong gas smell after driving.
The vehicle smells like gasoline after being driven and smells like gasoline when stationary. The power steering will display a warming message and the car will become hard to steer.
Throttle body position sensor again and again causes major loss of power and sometimes results in stalling out in seconds.
Extremely strong fuel smell has begun this week after driving vehicle and is parked. See no leaks of gasoline around vehicle. Has low mileage for age, under 90,000 miles. Certain areas have been recalled for this, but not for my VIN# at this time. Has to be same problem. Sounds identical. I will need to have my 2007 Saturn Ion inspected.
Tl the contact owns a 2007 Saturn Ion. The contact smelled a fuel odor after parking the vehicle and noticed fuel leaking from the rear passenger side of the vehicle. The dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer stated that there were no recalls. The contact referenced NHTSA campaign number: 12v459000 (fuel system) as a possible solution. The failure mileage was 47,407.
Very strong odor of gas after car has been running. Have read there are recalls on this car but the VIN does not say it has one.
I starded smelling gas real strong when I got out of my car so I checked to see if there were a recall on it I found one on cartruckinfo. Com so I called mcclinton dealership and told them what I found they said they didn't have a recall on it but they had something else that would cover it so I take it in after a while they call me tell me it's not covered because in has a salvage title and would coast me 2,ooo and something dollar's I live on $735. 00 a month that is the only transportation I have.
We notice a fuel odor while the vehicle is being driven or after it is parked. A crack has become large enough for fuel to be observed dripping onto the ground and vehicle performance has been affected. (#09275c).
Same issue as your recall from 2012, the fuel module cracked and leaked gasoline. Nhtsa campaign number: 12v459000 was your previous information and my car, although not included in the original recall, just had the same dangerous issue.
Gas leaks only at the clip.
The contact owns a 2007 Saturn Ion. While idling, the vehicle experienced misfires and had an abnormal fuel odor. Additionally, the check engine and air bag warning indicators illuminated. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The contact referenced NHTSA campaign number: 09v419000 (fuel system, gasoline), but the VIN was excluded. The failure mileage was approximately 114,000.
Strong gas smell noticed outside the vehicle as it was parked. Two days later had the oil changed at a local shop and they pointed out there was gas leaking by the exhaust pipe area at a connection. Took to draper Chevrolet who locally handles Saturn recalls and was told the gas line needed to be replaced and not covered by special case scenario. The repair was quoted at $568. Repair has not been made. Leaking fuel is an immediate hazard if in the presence of an open flame or possible accidents. It appears there are a huge number of cases where the fuel line has leaked on this model. It should be covered.
My gas peddle sticks!.
The contact owns a 2007 Saturn Ion. The contact sated that the engine hesitated to start and the vehicle emitted a strong fuel odor. The contact took the vehicle to an independent for diagnostic testing, which located a fuel line leak at the rear driver side wheel area. The fuel line was found fractured due to corrosion. The vehicle was not repaired. The manufacturer was not notified. The approximate failure mileage was 115,000.
The contact owns a 2007 Saturn Ion. While driving various speeds, a fuel odor entered the vehicle. Upon further inspection, a fuel leak was discovered under the vehicle. The vehicle was not diagnosed or repaired. The VIN was not included in NHTSA campaign number: 12v459000 (fuel system, gasoline). The manufacturer was notified of the failure. The approximate failure mileage was 109,000.
The contact owns a 2007 Saturn Ion. While the vehicle was stationary, the fuel lines rusted without warning. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the issue. The failure mileage was 109,000.
Tl-the contact owns a 2007 general motors Saturn Ion . The contact called the dealer and and the vehicle was dagnosed but not repaired. The contact stated that the fuel line coroded due to age and weather. The fuel line needs to be replaced the contact called the manufacturer to alert them of the problem the manufacturer stated that the vehicle was not a part of a recall and out of warranty. The approximate failure mileage was 115694. Am.
Tl-the contact owns a 2007 Saturn Ion. The contact stated that gasoline fuel fumes emitted inside and outside of the vehicle. The vehicle was taken to the dealership where it was diagnosed that the fuel line was rusted and needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 100,000. Ng.
Ever since I purchased this vehicle in October I've been having trouble & its only January I've had a fuel leak and had to replace it I've had bad struts had to replace it bad alternator replaced it bad battery replaced it bad brakes & rotors & I replaced it. It's just a horrible car and I wish I had spent my money else where is it possible that I trade in this car for something the same value I am very unsatisfied with this car.
Tl-the contact owns a 2007 Saturn Ion. The contact stated while observing the vehicle there was a strong fuel odor and there was fuel leaking from the vehicle. The contact also stated there was a gasoline puddle underneath the vehicle. The vehicle was towed to a dealer where the diagnosis was rusted fuel line failed and needed to be replaced. The vehicle was not repaired. The VIN was not included in NHTSA campaign number: 12v459000 (fuel system, gasoline). The manufacturer was notified of the failure. The approximate failure mileage was 47,813. Ak.
Substandard fuel line completely rotted in 2 places due to salt from winter months.
While driving started to smell a very rank gas smell rushed to my mothers house to see gas leaking all on the side of the car.
The contact owns a 2007 Saturn Ion. While driving approximately 40 mph, a fuel odor emitted in and around the vehicle. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure. The VIN was not included in NHTSA campaign number: 12v459000 (fuel system, gasoline). The failure mileage was 129,000.
I had a fuel leak from my Saturn and brought it to bob johnson Chevrolet to get repaired. They found that the fuel line was rusted at the driver side back by the tire and wants to charge me 750. 00. Now, I have researched the problem and found that I am not the only one having this same problem. There seems to be multiple people having this same issue at the same area as me. Chevy or my warranty company will not cover it. There has to be something with the Saturn Ions that is making them rust. The vehicle is too dangerous to drive d/t the leak is over by the tail pipe possible to cause a fire and explosion. There needs to be a recall to cause gm to redesign the fuel line to keep it from rusting and leaking that could cause a fire.
Gasoline dripping from area near rear wheels, both metal fuel lines rusted through.
The contact owns a 2007 Saturn Ion. While the vehicle was parked, the contact smelled a strong fuel odor inside and outside the vehicle and noticed fuel on the ground. The contact was a certified mechanic and diagnosed the vehicle himself. The contact stated that the fuel feed line and evap connector needed to be replaced. The vehicle was not repaired and the manufacturer was notified. The approximate failure mileage was 111,000.