Gas Recirculation Valve (egr Valve) Problems of Volvo S80

The contact owns a 1999 Volvo S80. While accelerating from a stop, the contact felt a thump from the driver side wheel. The failure occurred whenever she accelerated from a stop or decelerated. While the vehicle was parked, the contact noticed that the insulation surrounding the wires in the engine compartment were degraded. The vehicle also displayed difficulty when shifting into fourth gear. While driving approximately 70 mph, the contact could not shift out of third gear after attempting to accelerate from 40 mph. The failure occurred intermittently and the check engine light began to illuminate. The vehicle was taken to an authorized dealer where the contact was informed that the vehicle was not included in recalls 00v238000 (suspension: front: control arm: upper ball joint), 02v096000 (engine and engine cooling: cooling system: fan), and 06v441000 (vehicle speed control). The vehicle had not been repaired. The failure mileage was approximately 78,600 and the current mileage was approximately 79,100.

See all problems of the 1999 Volvo S80 🔎.

In early Jul 05, I experienced electronic throttle system (ets) problems with my 2000 Volvo S80. Particularly concerning to me from a safety standpoint was that several times, including when I was in highway driving situations, the car on its own suddenly accelerated and decelerated, hesitated on acceleration or would not accelerate, and displayed engine stall symptoms. The computer indicated degraded engine performance (limp mode). I lined up a service appointment with lovering Volvo of meredith. After lovering's first attempt at repairs, the car was still not operating normally and I took it back to the dealer a second time. I paid a total of $2,074. 42 for repairs, $1,741. 44 the first time and $332. 98 during the second visit. In accordance with a June 2006 Volvo letter, I took my S80 back to lovering for inspection and ets software upgrade. I submitted to Volvo a claim for reimbursement for ets repairs. The advertising checking bureau (acb), which administers the ets warranty rebate program on behalf of Volvo, sent me a check for $747. 93 for the ets repairs. Acb said it was authorized to reimburse me only the $587. 93 cost of electronic throttle body, electronic throttle module reload, and gasket, and associated $160. 00 labor cost. Acb advised me to contact the Volvo customer care center. A Volvo customer care representative confirmed that acb had done as instructed and suggested that I take up the matter of the remaining repair costs with lovering. The lovering invoices, dated July 26, 2005 and August 8, 2005, indicate that a $295. 65 portion of the initial $1,741. 44 repair bill had to do with totally unrelated steering/suspension and engine mount repairs. Still questionable in my mind are the oxygen sensor repairs which added up to $897. 86 and the subsequent mass air flow sensor repairs which came to $332. 98. I suspect the problems are all ets-related and I am currently pursuing the matter with the dealership.

See all problems of the 2000 Volvo S80 🔎.

The contact owns a 1999 Volvo S80. While driving 40 mph, the vehicle began to slow down and the abs and engine indicators illuminated on the instrument panel. The vehicle was taken to the dealer and they stated that the trollis system needed to be replaced. The vehicle was repaired, but the failure recurred two weeks later. The vehicle was taken to the dealer again and they stated that the central module needed to be replaced. The vehicle was repaired. The manufacturer stated that the vehicle needed to be taken back to the dealer for further inspection. The failure mileage was 60,000 and current mileage was 97,000. Updated 1/8/09 the ball joint needed to be replaced, the heating system, throttle systems, engine cooling fan and the master cylinder all failed. The vehicle would accelerated on its own. The vehicle stalled on several occasions. The steering made a noise when it was turned. The dealer lubricated the steering. The dealer stated the vehicle needed an O2 sensor. The ignition switch was replaced. The inner tie rods were replaced. 01/14/09.