Air Conditioner Problems of Chevrolet Colorado

The contact owns a 2005 Chevrolet Colorado. While driving approximately 20 mph on normal road conditions, the air conditioner system was activated; however, without warning it failed to operate normally. The driver observed underneath the front passenger dashboard that the air conditioner wiring melted. The vehicle has not been repaired. The contact is aware of the safety risk involved. The failure and current mileages were 48,000.

See all problems of the 2005 Chevrolet Colorado 🔎.

Ac speed regulator of my 2004 crew-cab Colorado overheated so much that the adapter burnt in the inside and cables overheated to the point that it couldn't be touched. This is located underneath the glovebox compartmen. If this is left unattended could cause a fire inside the vehicle.

See all problems of the 2004 Chevrolet Colorado 🔎.

Blower motor on a/c quit working on truck on speeds 1,2,3 still works on 4, checked on the internet and the problem is with the resistor module that controls the speed of the blower. Spoke to gm dealer,and he advised that the problem was with the module overheating and causing the plug to melt and cause the resistor pack to become inoperable. No warranty on part according to gm dealer, wants $76 to fix problem, I am not paying for part due to obvious manufacturer defect that is a possible safety hazard that can and will cause risk of fire, injury or death.

The consumer stated the vehicle has push buttons to change to 4-wheel drive. Without warning the vehicle changed from 2-wheel drive to 4-wheel drive without touching the controls. The dealer changed the computer and said they could not find the cause of the problem. Caller said loaner vehicle did the same thing. Manufacturer said they could not find the cause of the problem either. Had vehicle 7 times at dealer for this problem. The air condition was not cooling properly, therefore the dealer replaced the ac condenser.