Other Fuel System Tank Assembly Problems of Dodge Charger - part 1

Every time I fill my car up with gas and drive off from the gas station into on coming traffic the car will stall in the middle of the road I almost got hit in the side just yesterday. I got online and did some research and found out that there is a problem with the gas tanks on these cars that cause them to stall after putting gas in them.

See all problems of the 2006 Dodge Charger 🔎.

Filled gas tank, did not top off. Left parking lot and the car died going down the road. Happened 3 times that day. Has happened many times since November 2020, didn't know you had complaint line. This left me with no steering or brakes. It has now gotten to the point of the car won't even start now. I am afraid that damage from this issue has 'taken' my car, as it will no longer start. We upkeep our vehicles with regular maintenance.

2006 Dodge Charger daytona r/t randomly stalls while driving or parked. No check engine light gets produced. In that split second that it shuts off, the car loses power completely and no brakes or power steering. This is extremely dangerous, and Dodge should issue a recall immediately to fix this issue. Most sources point to a faulty gas tank that has a lifetime warranty now but should be recalled.

I filled my gas tank up and when I did as I was driving at around 15-20mph my car stalled on me and later on it shut off as I was coming to a stop this happens every time I fill my gas tank up.

Evap has system has a small leak. My gas is leaking from the opposite side of the gas tank . The check engine light just came on. The gas leaked 2 weeks ago and now the check engine light is on and I keep smelling gas . The car was stationary.

See all problems of the 2017 Dodge Charger 🔎.

When my tank is full to around half full it leaks gas and there is a very strong smell on the back passenger side outside of the car. Inside of the car is intolerable. You have to drive with the windows down. I've read this is a common and very dangerous Charger problem but yet there is no recall.

See all problems of the 2011 Dodge Charger 🔎.

Tl the contact owns a 2006 Dodge Charger. The contact stated that the vehicle stalled when the fuel tank was filled up completely. The contact was able to restart the vehicle with no further issues. The contact called the manufacturer and was informed that the vehicle was not included in a recall. The manufacturer informed the contact to call NHTSA. The dealer was not contacted. The vehicle was not diagnosed or repaired. The failuire mileage was 64,000.

Takata recall my Dodge is fairly new. A 2010 and the gas gauge has completely stopped reading correctly. It'll die when it reads there's a quarter of a tank left or even when it says there is half a tank left. I've been in multiple situations when the car has died and I read a lot of forums with people the same make model having this issue.

See all problems of the 2010 Dodge Charger 🔎.

Recently, after pumping gas into my car and after driving for a few moments, the car stops as I approach a stop sign or a light. This has happened to me immediately after at least 3 recent gas fill-ups. I shut off my car and start it up again and after driving a short period, it happens again. This only happens after I pump gas into my vehicle (2006 Dodge Charger r/t). This has happened on city streets as I am fearful of going on the expressways with the possibility of it stalling and stopping. I believe there is a faulty valve or gas tank situation.

Filled up tank. Drove car for 1/2 hour approx 30 miles. While making a left hand turn at a low rate of speed the car stalled, shut it self off. The oil lamp and traction control light came on. Car would not fire back up. Took a few attempts. Upon restarting the car was running rough. Continue driving at very low speed attempting to turn into parking stall car again stalled and shut it self off. Felt the car was unsafe to drive home. Had it towed.

After fueling gas tank to full level the car starts and runs fine for approximately two blocks down the street then the engine abruptly shuts off and stalls in traffic (dangerous). The vehicle requires restarting twice more before it will run normally. This happens every time the gas tank is fully filled. No problem if the tank is filled less than full. This has occurred the last three times gas tank was fully fueled. 2006 Dodge Charger srt8 6. 1l hemi.

Takata inflators. When I fill the tank with gas and start driving it will sputter, jerk and stall. When it stalls and I finally get it started, I press on the gas lightly it doesn't move and then it lunges forward. This just started in the last month, but it now happens every time I fill the tank for about the first 20-30 miles driven. I've read that his is an issue with these cars. I also see the warranty has been extended to many vehicles regarding this issue but on this particular car there is no recall for this VIN. The car has 57500 miles on it.

The vehicle stalls while driving, no matter the speed, and the power steering goes out when vehicle stalls preventing me from being able to steer the vehicle. This has happened several times, even on the interstate with other fast moving vehicles behind me, and is very dangerous. I have had different parts replaced trying to fix the problem, and was told the entire fuel tank will have to be replaced to solve the problem. I went online to see if other Dodge owners experienced the same problem, and was amazed at the thousands of people complaining about the exact same thing. This website is one of many. . Read more...

Car stutters and shuts off after I fuel up my 19gal gas tank. Car turns off when idle after fueling up. Did see that for my make and model and year of car there were warranties extended for gas tank to be replaced with the same issue, never received a recall for my vehicle. And dealership will not touch my gas tank.

Strong fuel order when fill gas tank. I looked online it looks like a common issue. This is extremely dangerous someone's going to get killed if it hasn't happened already. The gas leaks out at the top of the fuel sending unit located under rear seat on the passengers side. When I took the seat off there was a puddle of fuel. Again this is extremely dangerous and seems to be a very common issue after reading online.

Gas tank is leaking on top right side, when full. Dealership says there is no recall. Need a recall. Fast!.

I started smelling gas inside my car. I noticed a wet place on the ground under where my gas tank is. I took my car to my mechanic. He stated that when the tank is full, it is leaking on the top right side of my tank because that side is not welded correctly together. This is a safety hazard. I have children that ride in my car. My mechanic said just the cost of a new tank is $1,100. 00. That is not including the labor to remove the old one to put a new one in. This problem should be added as a recall due to so many others having the same issue.

My car started smelling like gas all the time. When I got back from the store I noticed the gas was leaking from the passenger side back door. There was a gas puddle and the inside of the car smelled like a lot of gas. My brother lifted the back seat and there was a lot of gas leaking from the fuel tank.

The car stalled as I was driving. I have looked up this issue before and people have said it has something to do with the fuel tank. A dealership has replaced the fuel tank a few months back and today it stalled again. This is the first time this has happened since replacing the fuel tank. It appears this is a bigger problem than just the fuel tank. There should be a recall placed before people are seriously hurt and/or killed. The car shuts off while driving. If it is on the freeway then it'll be catastrophic on what can happen. The car also loses steering when it shuts off causing a bigger problem.

"takata recall" the car has a raw fuel smell that fills the cabin and also the trunk area, especially when I fill tank. I have taken to 2 mechanics and they could not find a leak. The car does this moving and sitting still, running or off.

See all problems of the 2014 Dodge Charger 🔎.

Takata recall. . . . . Fuel tank is leaking while on the road and parked. Also breaks are flooring.

See all problems of the 2015 Dodge Charger 🔎.

Pump a full tank and the car stalls at low rpm on a city street when in motion and not in motion happen about 6 time after I put a full tank been goin on for about a month.

When I fill up the gas tank of my vehicle, starts properly and runs good for a few minutes then stalls, pull to the side of the road, start again and runs fine for a few more minutes and then it does it again, vehicle is in motion or stationary, it happen also twice when turning and power steering went out almost ran out of the road the first time and the second had to apply brakes hard in order to avoid collision with another vehicle, very un-safe and dangerous. When driven about 40-60 the problem goes away and then starts all over when gas tank is filled up again. I do not have photos, police report or any other documentation to upload and hope not to have any to get this issue resolved.

On the morning of 8/20 I drove 2 blocks from my house when the chattery save mode turned on accompanied by the battery light on the dash shortly after the car lost power steering and all electric components shut off and then the car shutoff and was immobile after that. I pushed the car home and the car hasn't turned over since. I disconnected the battery and used a battery Charger to recharge so I can put my windows up when I reconnected the battery I put the car in run knowing the alternator was bad and pending recall. As the windows hit the closed position black smoke started coming off the alternator and I promptly disconnected the battery again completely after turning the car into off position again. The alternator continued to smoke for 5 minutes as I stared at it with fire extinguisher in hand and phone in the other with 911 dialed and ready. As the car sat in the driveway after all this I noticed a fuel smell that came from the car then I noticed a fuel leak. A constant dripping of 1or 2 drops per 5seconds. The leak comes from below the door hinges area of the passenger side rear door. I cannot find the origin but this is where it drips from. I've read that this is also a common problem but Dodge or any other affiliate has recalled any fuel components and people that have changed the full fuel system tank hoses pumps everything still continue to have this issue when the vehicle is filled with gas to max capacity and the leak stops once the fuel level reaches 3/4 tanks or less.

The last time I filled up my car, it kept stalling and I would lose power steering and brakes while in traffic with my children in car. Not very safe feeling. Scared I was going to get hit with family in car. It would start up but it would keep stalling until I ran a few gallons out of it. I filled it up again today and noticed a sucking noise coming from gas tank. It started up then stalled as I took off. So I pulled over and kept starting it up every time it stalled. After about an hour of not stalling I drove home and parked in garage. It would stall going straight and turning.

Major safety issue. After refueling, my vehicle stalls anywhere from 1-6 times at random times. It happens at highway speeds, and city driving. There is a total loss of power (brakes and steering included) had a very close call of causing an accident due to this issue. This issue is supposedly covered by extended lifetime warranty but my VIN is not "eligible" for some reason. In order to fix the issue, the gas tank has to be replaced $1500+ expense. Very disappointed that Dodge abandon my here. Even though im experiencing the issue, im not eligible because my VIN range missed the lifetime warranty.

My car had a check engine light so I went to an official Dodge dealer to fix. They claimed it was a faulty valve in my fuel system and charged me $470 to fix. Since fixed, I filled up my gas tank and now whenever I enter my car, it smells of raw fuel. After driving for about 10 minutes, the smell goes away, but I have found many different people are complaining about it. I took it back to the dealer and they could not determine the reason it was smelling like gasoline. . I did not track fuel into my car and was not storing fuel in my trunk. The car did not smell like fuel before the initial repair.

My vehicle is a 2011 Dodge charge 80,000 miles. For about 4months its been smelling like fume, gasoline inside the vehicle like if there was a leak when the car is stationary, in motion at all times. When I fill my gas tank the smell gets worst. Since it began to smell like gasoline the check engine light has been on. I have not fixed the problem because mechanics are wanting approximately $500 to fix the gasoline fuel system. I hope I don't blow up. It is a unsafe condition to drive my vehicle because I have twin 1year olds. I have contacted the dealer to find if there is a recall but they state they don't.

When the car is filled with gas, it emits a strong odor of gas and leaks under the rear passage side of car approx. 16 inches in front of rear tire. As the tank gets lower of fuel, the smell is not as strong and leak disappears. This occurs when the car is parked. If the car is driven with a full fuel tank, there is a strong gas odor inside the cabin. This smell lessens as the fuel tank empties. I have taken video of the exterior fuel leak approx. 17 hours after fill up that show a steady fuel drip every 12-15 seconds.

If I fill up my tank of gas it starts leaking from underneath the vehicle. Fumes can be smelled inside of the vehicle and outside as well. Its very penetrating. When its hot outside if the car remains close when u arr inside the fumes begin to givr you a sore throat and short of breath. Very dangerous.

The contact owns a 2006 Dodge Charger. While driving various speeds, the valve inside of the fuel tank allowed raw fuel to enter into the fuel lines, which caused the vehicle to stall without warning. The dealer (mclnerney's woodhaven Chrysler, Dodge, Jeep located at 23940 allen rd, woodhaven, michigan, 48183) stated that the failure was under recall; however, the vehicle was not included. The manufacturer was made aware of the failure. The failure mileage was 23,000.

My 2006 Dodge Charger rt stalls intermittently while I'm turning a corner on a city street or stopped at a red light. When it stalls, I do not have power steering. This is extremely dangerous because I could get hit. Sometimes it stalls more often after I fill up with gas. I do not overfill. I have been filing my gas tank the same way for 10 years and until October of 2016 it has never been a problem.

Every time I fill up a strong odor of gas is observed inside the cabin of the car and area around the car until it get's down to about 1/2 tank of fuel. I've read several complaints and costing us consumers like $1,000. 00 to $1,800. 00.

Strong odor of gasoline whenever gas tank is full. Will make driver light headed.

As I approached my car there was a heavy odor of fuel. The next morning under the back right tire there was a puddle of fuel. I removed the back seat and under the cover there was a puddle of fuel on top of the plastic of the gas tank. Dodge has been clearly made aware of this issue and since changed the design of the gas tank. For me to replace it would cost me over $2,000. This should be replaced by Dodge ASAP. This puts my family and I in grave danger being that of the electrical wire that run along side the unit. This only happens when I fill my tank and it is a continual drip. I contacted Dodge and they said they "know" nothing of such issues. All it will take a one dropped cigarette to close to the car and things will be bad.