Front Suspension Strut Problems of Ford Focus

2002 Ford Focus. Consumer writes in regards to denial of reimbursement the consumer stated in may 2011, the right front spring fractured. The vehicle was towed to a local repair shop where both the left and front spring/strut assemblies were replaced. The consumer learned Ford had issued a technical service bulletin advising dealers that certain Focus vehicles including his were susceptible to front spring fracture failures due to inadequate corrosion protection. The consumer was denied reimbursement, because he did not take his vehicle to a Ford dealer for repairs.

See all problems of the 2002 Ford Focus 🔎.

Broken spring in front of 2000 Ford Focus. Leading to other unsafe conditions on the car. Strut bearings,control links unstable steering vibration.

See all problems of the 2000 Ford Focus 🔎.

While driving my 2000 Ford Focus sedan upon exiting the parkway Saturday evening March 18, 2006, I heard a loud thud from within the front end, like something had snapped. Nothing looked to be wrong. A short time later, the vehicle started to emanate a loud high-pitched grinding noise and then a lot of smoke. What happened is the front right wheel suspension spring snapped off the strut and gorged a deep trough or groove in my tire. Fortunately the tire was brand new. If this had happened while I was driving on the parkway a few minutes before, no doubt the tire would have blown and sent me careening out of control. My mechanic put the car up on a lift so I could take photographs. My mechanic is making the repairs today. He reports the strut spring broke in three separate places. The front tire is destroyed and rendered totally useless. The odometer reading is 66,662 miles. The defective parts will be retained and made available for physical inspection. I am sending my photos as an attachment with my e-mail message to the NHTSA at their following address: webmaster@NHTSA. Dot. Gov I have never experienced this type of mechanical failure in any other vehicle make or model and I have been driving continuously since 1965. You will observe that a number of identical mechanical failures involving the Ford Focus struts and springs are posted by others at the NHTSA web site. The mechanic informed the consumer the front strut broke which caused the front coil spring to break into three pieces. Updated 04/04/06. Updated 05/25/jb.

Always noted a rattling, which I was told was a strut noise, but nothing was wrong. Two weeks ago the right side strut spring broke and nearly destroyed a tire. Had to be towed, and then had spring replaced. 10 days later the left side spring broke as I entered driveway. Many reliable sources have informed me that there was no way a 2000 vehicle with 67,000 miles should have these problems. The warranty expired. . Bottom line was that Ford used either inferior or defective springs on a important part of the car.

1) noise coming from right front 2) both front springs and struts had to be replaced because the right front spring had broken and cut the right front tire down the middle (which also had to be replaced). The spring also bent the strut. 3) all old parts are available - see #2 for what was done to correct failure. Repairs had to be made on an emergency basis.

Front mcpherson struts were replaced due to vehicle making clunking noises when making turns at low speeds or at high speeds. Contacted dealer, and dealer replaced struts, but solution did not work.