Ford Freestar owners have reported 38 suspension related problems since 1996. Table 1 shows the 10 most common suspension problems. The number one most common problem is related to the vehicle's suspension (17 problems). The second most common problem is related to the vehicle's front suspension wheel bearing (6 problems). For details of each of the problem category, use the links in the table.
I purchased a 2006 Ford Freestar van on 10-13-2020 and 10-16-2020 car lights started blinking on and off in an outside the van. Started to drive home the van started jerking bad and smoking. Cut off in the middle of the road while my children an pregnant daughter in law were in the van. Read details...
2007 Ford Freestar sel front wheel bearing hubs making a very high pitch whistling niose. Obviously this is a very well known problem by the number of complaints listed online. I think this should be a recall item. Read details...
Tl the contact owns a 2004 Ford Freestar. While the vehicle was undergoing routine maintenance by an independent mechanic, the contact was informed that the control arm was protruding through the frame and created a hole. In addition, the check engine indicator illuminated. Read details...
The contact owns a 2004 Ford Freestar. While traveling 30 mph, the contact noticed that the front suspension and axle had suddenly separated from the vehicle, causing the vehicle to crash into a parked vehicle. No one was injured during the crash. Read details...
The contact owns a 2006 Ford Freestar. While driving approximately 15 mph, the contact stated that the front axle fractured and was repaired by a local mechanic. However, the front axle fractured again. The vehicle had not been repaired. The manufacturer had not been notified. Read details...