general problems of the 2005 Nissan Titan - part 2

I have a 2005 Nissan Titan with only 44000 miles on it. During recent driving it sounded as if the right rear was grinding to pieces. It continually got worse so I looked under the truck to see if there was something that was caught and dragging. It was so loud that people would stare at the truck when it passed by. After it was taken to the garage they discovered that the insides of the right rear axle were almost completely torn apart. It was very fortunate that it did not cause a serious problem while driving. They also found that the left axle was leaking and would likely also break down. The cost to repair the truck was over $1700. 00.

Both rear axle seals leaked at 38,xxx in 9/2009 and were replaced under warranty. No issues for two years. In 8/2011 driver side is leaking again. Tried to express my concerns to Nissan and was rejected because of "warranty" issues. Seems to be an inherent problem experienced by a lot of 04-07' Titan/armada owners. TSB issued by Nissan to replace entire axle assembly 5 months after my first leak, but they don't feel it's their responsibility to notify owners who experienced the issue prior to the bulletin. Was told by a Nissan rep. That the TSB is a guideline for techs. To properly fix an issue if it arises. I had the issue but it was 5 months before they figured out how to do a "proper" fix, and according to them it doesn't apply to me unless the part or labor or drivetrain was still under warranty. Was told that if this was a widespread issue they might offer good faith credit. Curious as to how many it will take for them to not turn the blind eye to an obvious problem with what I feel is a safety issue. If there is a problem with the drive axle of a vehicle, I believe that should qualify as a safety issue or recall.

Nissan Titan 2005 37,000 miles rear axel seal leaks.

The axle seals leak intermittingly on both the driver and passenger side, rear axle. Gear oil leaks out and coats the backside of the brake/wheel assembly. This is the second incident on the driver side. The first time it was fixed under warranty at approximately 20000 miles. The passenger side axle seals were fixed under warranty at approximately 25000 miles.

Rear axle seals leaking replaced at 55,000 and now again at 68,000.

I purchased a use 2005 Nissan Titan 4x4 in may of 2010. In December 2010 I went to engage the front wheel drive due to driving up a road that had snow and ice. After complying with the directions in the owner's manual I began driving up the grade only to find that I had no pull from the front wheels. This almost resulted in the loss of control of the vehicle due to loss traction on the road. One time the front of the vehicle complete slide back down the hill, causing the vehicle to do a complete 180 degree turn. Days later I took the vehicle to my mechanic and found the front axle had become detached. They advised me that this was the second Titan they had seen do this and had heard that Titans had a problem detaching when driven in four wheel drive mode on dry pavement and the vehicles would make sharp turns. Luckily, my incident did not result in any crashes, however it did come close to striking fixed objects along the road.

I have a 2005 Nissan Titan. The rear axle is leaking all over the rear brakes causing a safety issue with the brakes. It could cause braking failure or a fire in the rear brakes. Nothing has happened yet but could potentially cause a bad accident to happen if someone owning this vehicle didn't realize that the rear axle was leaking.

I own a 2005 Nissan Titan pickup which I purchased new. The vehicle has 57,000 miles. My driveway is steep as I live in a remote location. About two weeks ago I was headed to town. The rear end went out and my Titan slid off the roadway. The mechanic who is repairing my vehicle told me this was a very common problem with my model of vehicle. I checked on line and found many similar incidents. I contacted Nissan and found there was no recall regarding this. Repair cost is now over $2000.

2005 Nissan Titan rear axle seal leaking at 42,000 miles. Dealer said there is a defect but not a recall. They want to replace whole axle to prevent seal leaking again. There are thousands of complaints on this issue and it is a safety issue that should be recalled.

2004-2008 Titan; rear axle seal leaks. Mine is a 05'. Right rear wheel well is covered with oil and the inside of the tire is flooded with oil also. 55k miles and from what I understand I was lucky it lasted this long. Dealership wants $1,500+ to fix a problem that seems to be a defect not just wear and tear.

Both rear axle seals leaking. Had a complete rear end replacement at 58,000 miles. Currently have 100,000 miles and both rear seals are leaking again. I towed a 2990 lbs trailer from michigan to west virginia, the morning after getting home I noticed the leaks and popping in rear end when pulling out. First time towing with this truck. Mileage is all highway. Commuted 120 miles per day to work. I have been on forums and seen countless others with same problem. Nissan is very aware of the problem and will not even make parts available. They are just replacing the entire rear ends. This is a common problem with these trucks and I would like to know why a recall has not been issued for it. Not sure what to do other than fix it one more time and then sue under lemon law when it happens again.

I had a 2005 Nissan Titan truck. The real axle seal broke and the oil came into the rear brake when I was on interstate highway from FL back to va. I had to drive so slow to make it back home and had it replace for $500. Few weeks later now I have a front drive axle seal broke and oil is leaking. I am bringing to dealer and replace today.

Ok I have a 2005 Nissan titian I bought from [xxx]in little rock very good guy, its a 4wd never been in the mud not once well just yesterday I pulled out to follow my friend [xxx] to subway when I did my whole truck jerked and made a loud pop then everytime I turned it made the same noise and when I drove to the shop with it was bouncing my whole tailgate up and down. . . Come to find out that my rear end burned up in my truck and was going to b about as much money to put a new engine in to get it fixed. . . . I have never seen a rear end go out on a truck that's practically new with only 100k miles on it. . . Very disappointed will not being buying another titian again ima stick with Toyota. Information redacted pursuant to the freedom of information act (foia), 5 u. S. C. 552(b)(6).

Rear axle seal leaking, it is leaking so bad that it is all over my rear passenger side brakes. I noticed the brakes slipping yesterday when I trying to stop on the highway. 05 Nissan Titan.

The rear axle seals are leaking on my 2005 Nissan Titan. The oil is running from the axle seals on to the rear brake rotors and rear brake pads. This can result in rear brake failure and can cause a crash.

The rear end was replaced before I bought the truck and just 3 years later I had to have the left rear axle seal replaced and now im having to replace the right side axle seal. Im not too sure that its not damaged the rear end itself. I had a case number with Nissan north America but because of the time its been out of warranty they wont replace anything. There are too many people who are having the same problem with theirs for there not to be something done about it. These seals should not be going out that quick.

Heard my brakes squeaking and started to investigate. Saw oil residue on the inside of the wheel and it was on the brakes as well. The oil was coming from the axle. The seal is bad. No accidents yet, but this could cause an accident if I needed to stop in a hurry with oil on my brakes!!!.

Truck started making clunk noise 5 months ago every one in a while I thought it was stuff in the bed of the truck. Last night I was turning a corner is made a the clunk noise and every turn I took under power made the clunk noise and when I start from a stop on wet driving surfaces.

Loud roar from rear of truck. Once it started it got worse over a short period of time. Carried to dealer and was told rear end gear failure. Dealer replaced rear end. I called Nissan because only 10,000 out of warranty but turned down. If rear end had went out at speed this could be very dangerous. . . Nissan needs to repair these trucks!.

4" inches of new snow. Before leaving work, I engaged 4x4 high. Pulling out from a stop light, I noticed it didn't feel like the 4x4 was working. Next morning, had a big puddle of diff fluid on ground. Took it to the Nissan dealership, and was told front diff was junk. This truck has been put in 4x4 high maybe 5 times in 80,000, always on icy roads.

Front axle on drivers side locked up and made me run off of the path . The dealership is saying they will not fix it .

I own a 2005 Nissan Titan while driving down the road the rear end started popping and lost power. Truck has 62000 miles on it . I don't tow anything with it. I took truck to the dealer,they stated this is a common problem, dealer wanted $3500 to replace the entire rear end ! if so many trucks made by Nissan are having the same issue why have you not made them recall this item. The rear end in this truck is dangerous, if it hasn't already it will get someone hurt or killed .

Pulling out of parking spot. Loud noise heard along with clunking feeling in rear of vehicle.

Rear end seals and axles leaking and corrosion on a 2005 Nissan Titan.

1. Casual driving/limited towing 2. Electronic slip diff failure 3. Still at shop currently looking at $3,800 bill to fix.

Defective axle seals.

Rear axle seals leaking on the rear brakes.

Rear went out of 2005 Nissan Titan. Was preceded by clunking, vibration. Right rear axle seal was replaced by dealer prior and under warranty for leaking at approx. 48k miles. Nissan will not replace the rear since it is over on the mileage by 12k miles even though it had to have work done to it while it was under warranty. Nothing has been to it, it sits.

I own a 2005 Nissan Titan, I do not tow anything with it and I do no off road driving. In 2009 with 65000 miles my rear end started making a loud noise. I took it in to dealer to get looked at. Dealer told me it would cost $2600. 00 to put new one in. Also there was nothing they could do warrenty was up just 5000miles ago.

Multiple failures of right rear axle seal. Failures at mileages of 42186/86082/106492/131033. Same parts replaced 43252-7s200 rear axle seal, 43070-7s200 rear spacer, 40210-7s210 axle bearing. Axle fluid drains directly on to brake causing loss of function on right rear wheel. Also has caused possible premature shock absorber wear.

Nissan Titan 2005 se 4x4 with tow package 49,000 miles. Rear end broke taking off from stop sign. Dealer is having a hard time getting a replacement. It has been at the dealer since the 5th. Talked to Nissan customer service and they don't want to help me. Truck is still under warranty.

Just heard from my Nissan dealer, they said my rear axle seals are leaking. I read this could cause braking issues. This truck has 61,000 miles and the Nissan Titan's have been know to have faulty rear axle seals. Dealer wants me to replace, but seem where it is a safety concern that it shouldn't be my responsibility to replace especially at 61,000 miles. This should be a long term wear item.

I wish I would have check this website before buying the 05 Titan. Went in for oil change and tech. Informed me of leaky seals training and play in u joint need to be replaced under warranty thank god, but after reading all of the complaints on this website I don't think I'd would have bought this truck.

2005 Nissan Titan 4x4 front axle failure. The four wheel drive is inoperable ar a result of a known design flaw in this vehicle.

Rear axle seal is leaking so bad the rear brakes are saturated.