Other Fuel System Problems of Saturn ION - part 2

Saturn ION owners have reported 176 problems related to other fuel system (under the other fuel system category). The most recently reported issues are listed below. Also please check out the statistics and reliability analysis of Saturn ION based on all problems reported for the ION.

36 Other Fuel System problem of the 2006 Saturn ION

Failure Date: 10/26/2017

Engine reduction, serious safety concern, was almost hit by a semi, engine reduction light comes on, lose power and car slows at a high rate causing extreme safety hazard in traffic, must pull off interstate turn car off to reset, happening 2-3 times a day, strong smell of gas, have a leak and it is not covered under the warranty, sooner or later someone is going to be cruising down the interstate and their Saturn is going to reduce engine power and they will not have time to get out of the way, they will be plowed down by a semi. Are we going to continue to allow gm to ignore this issue like they ignored the ignition switch probelms until it starts causing deaths, why not solve the issue before the deaths start to occur, it seems the older these year models get the worse this problem becomes. I was forced to put a date, but this is an ongoing problem that is getting increasingly worse with the fuel leak, maybe one day the engine will reduce power at the same time I will get run over by a semi and the car will explode into flames from the fuel leak they are not recalling for my vehicle.

See all problems of the 2006 Saturn ION 🔎.

37 Other Fuel System problem of the 2007 Saturn ION

Failure Date: 10/23/2017

Very strong odor of gas after car has been running. Have read there are recalls on this car but the VIN does not say it has one.

See all problems of the 2007 Saturn ION 🔎.

38 Other Fuel System problem of the 2007 Saturn ION

Failure Date: 09/16/2017

I starded smelling gas real strong when I got out of my car so I checked to see if there were a recall on it I found one on cartruckinfo. Com so I called mcclinton dealership and told them what I found they said they didn't have a recall on it but they had something else that would cover it so I take it in after a while they call me tell me it's not covered because in has a salvage title and would coast me 2,ooo and something dollar's I live on $735. 00 a month that is the only transportation I have.

39 Other Fuel System problem of the 2006 Saturn ION

Failure Date: 09/15/2017

The contact owns a 2006 Saturn Ion. While driving various speeds, a fuel odor emitted through the vents. The contact also noticed the fuel odor coming from the floorboard. The contact called schmidt Chevrolet Cadillac (3423 broadway st, mt vernon, IL 62864, phone number: (618) 242-5100) and was informed that the vehicle had to be towed if there was a fuel leak. The vehicle was not taken to the dealer. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The approximate failure mileage was 200,000.

40 Other Fuel System problem of the 2003 Saturn ION

Failure Date: 09/08/2017

Gas odor coming from under vehicle. Fuel line next to frame directly under left rear passenger seat was leaking, fuel lines were rusted through causing gas to leak. Fire hazard.

See all problems of the 2003 Saturn ION 🔎.

41 Other Fuel System problem of the 2007 Saturn ION

Failure Date: 09/01/2017

We notice a fuel odor while the vehicle is being driven or after it is parked. A crack has become large enough for fuel to be observed dripping onto the ground and vehicle performance has been affected. (#09275c).

42 Other Fuel System problem of the 2005 Saturn ION

Failure Date: 08/26/2017

College aged daughter owns and drives a 2005 Saturn Ion with approximately 115,000 miles. We noticed a wet spots on the ground on the drivers side near the rear passenger door when car is stationary (parked) but never detected an odor. Took vehicle to Nissan dealership in maryland since we were unaware that gm owns Saturn. However, we were told by Nissan that fuel lines need to be replaced because the vehicle is leaking gasoline and repairs should be done immediately because it is both unsafe and dangerous.

See all problems of the 2005 Saturn ION 🔎.

43 Other Fuel System problem of the 2003 Saturn ION

Failure Date: 07/16/2017

Same issue as in Saturn Ion 2004 recall: rusted area on fuel line near rear door. Very sudden fuel leak (half gallon) when I arrived home and parked my car.

44 Other Fuel System problem of the 2005 Saturn ION

Failure Date: 06/26/2017

The contact owns a 2005 Saturn Ion. The contact stated that when he started the vehicle, he noticed an abnormal fuel odor without warning. In addition, once the contact reached his destination he observed fuel leaking out from under the rear passenger side of the vehicle. The vehicle was not diagnosed or repaired. The manufacturer nor the dealer were notified of the failure. The failure mileage was approximately 250,000.

45 Other Fuel System problem of the 2005 Saturn ION

Failure Date: 06/07/2017

The contact's daughter owns a 2005 Saturn Ion. Each time the vehicle was parked, the contact noticed oil spots on the ground. Upon further inspection, the contacted husband noticed that the fuel line was cracked and leaked fuel in the front of the rear driver?s side wheel. There were no warning indicators illuminated. The contact was concerned that the fuel leakage could cause a fire. The contact called the dealer (guy's Buick gems, 1316 n mildred st, ransom, wv 25438 304-725-3448) and was informed that there no recalls were on the vehicle. The dealer was unable to schedule an appointment and stated that they would call the contact back. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 100,000.

46 Other Fuel System problem of the 2007 Saturn ION

Failure Date: 06/06/2017

Same issue as your recall from 2012, the fuel module cracked and leaked gasoline. Nhtsa campaign number: 12v459000 was your previous information and my car, although not included in the original recall, just had the same dangerous issue.

47 Other Fuel System problem of the 2006 Saturn ION

Failure Date: 06/01/2017

Tl- the contact owns a 2006 Saturn Ion. The contact stated that while reversing at 1 mph, the contact noted a fuel odor in the vehicle. The vehicle was taken to an independent mechanic where it was diagnosed that there was a leak in the fuel lines due to the material in the fuel lines having rotted and failed. The vehicle was not repaired. The contact also spoke to herb chambers Cadillac of warwick 1511 bald hill rd, warwick, ri 02886 who advised the contact to tow the vehicle over to have it diagnosed under a potential warranty extension. The vehicle was not repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 97,656. Np.

48 Other Fuel System problem of the 2004 Saturn ION

Failure Date: 04/02/2017

I bought a 2004 Saturn Ion 2. 2l l4 (VIN: 1g8aj52f74z205097) for my son 4 months ago. It is now leaking a puddle gasoline after being shut down. I looked on line and there dozens of others with this problem (please see attached) yet my VIN is not on a recall list. Called Saturn 800. 972. 8876, they said it wasn't on a recall list also. Dealer wants $600+ for repairs. Any suggestions? thanks.

See all problems of the 2004 Saturn ION 🔎.

49 Other Fuel System problem of the 2004 Saturn ION

Failure Date: 03/27/2017

The car is under 80,000 miles and has a leaking fuel line.

50 Other Fuel System problem of the 2007 Saturn ION

Failure Date: 02/19/2017

Gas leaks only at the clip.

51 Other Fuel System problem of the 2007 Saturn ION

Failure Date: 02/15/2017

The contact owns a 2007 Saturn Ion. While idling, the vehicle experienced misfires and had an abnormal fuel odor. Additionally, the check engine and air bag warning indicators illuminated. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The contact referenced NHTSA campaign number: 09v419000 (fuel system, gasoline), but the VIN was excluded. The failure mileage was approximately 114,000.

52 Other Fuel System problem of the 2004 Saturn ION

Failure Date: 02/05/2017

Strong gas smell & started noticing poor gas mileage and it got worse. Then notice it is leaking gas by the rear driver side tire. Also the running lights automatically come on during the day but not at night.

53 Other Fuel System problem of the 2007 Saturn ION

Failure Date: 01/25/2017

Strong gas smell noticed outside the vehicle as it was parked. Two days later had the oil changed at a local shop and they pointed out there was gas leaking by the exhaust pipe area at a connection. Took to draper Chevrolet who locally handles Saturn recalls and was told the gas line needed to be replaced and not covered by special case scenario. The repair was quoted at $568. Repair has not been made. Leaking fuel is an immediate hazard if in the presence of an open flame or possible accidents. It appears there are a huge number of cases where the fuel line has leaked on this model. It should be covered.

54 Other Fuel System problem of the 2007 Saturn ION

Failure Date: 01/15/2017

My gas peddle sticks!.

55 Other Fuel System problem of the 2006 Saturn ION

Failure Date: 01/10/2017

Strong smell of fuel at rear of car after driving, and while parked and running. I noted the recall notice affecting these cars with this problem, however, when I searched, I found that this recall did not affect my VIN number. This car is a special rare version of this type of car called the "redline" edition, and so the VIN may not come up automatically, as only about 600 were made that year. I am planning on talking to the dealership.

56 Other Fuel System problem of the 2004 Saturn ION

Failure Date: 11/30/2016

I have had 3 mechanics look at my 2004 Saturn Ion. I have been advised that my fuel lines need replaced due to leaking. However, my vehicle's VIN number is not associated with the recall on this product and it should be.

57 Other Fuel System problem of the 2004 Saturn ION

Failure Date: 10/25/2016

After the car was looked at by a chevy dealer to have recalls preformed and the fuel leak looked at, they said, on paper, "c/s fuel leaking under vehicle. " "fuel feed line leaking fuel,active leak,do not recommend to drive. Replace for $689. 99 plus tax customer declined. " I declined because that's a lot of money, which I will take their caution and not drive the vehicle till it can fixed. I am bringing the car to another mechanic to have their claims verified by a none gm company. I live in NY, they used to use salts on the road which may have attributed to the issue, the car is 12 years old at only 62k miles. Disappointing. Car was bought used. 1 month ago at 61k miles privately, I assume the seller sold the car due to the gas leak and didn't inform me.

58 Other Fuel System problem of the 2004 Saturn ION

Failure Date: 10/15/2016

The contact owns a 2004 Saturn Ion. While the vehicle was parked, the contact noticed a strong fuel odor. In addition, fuel leaked from the rear of the vehicle. The vehicle was not diagnosed or repaired. The VIN was not included in NHTSA campaign number: 04v003000 (fuel system, gasoline). The manufacturer was notified of the failure. The failure mileage was 62,000.

59 Other Fuel System problem of the 2007 Saturn ION

Failure Date: 09/28/2016

The contact owns a 2007 Saturn Ion. The contact sated that the engine hesitated to start and the vehicle emitted a strong fuel odor. The contact took the vehicle to an independent for diagnostic testing, which located a fuel line leak at the rear driver side wheel area. The fuel line was found fractured due to corrosion. The vehicle was not repaired. The manufacturer was not notified. The approximate failure mileage was 115,000.

60 Other Fuel System problem of the 2007 Saturn ION

Failure Date: 09/05/2016

The contact owns a 2007 Saturn Ion. While driving various speeds, a fuel odor entered the vehicle. Upon further inspection, a fuel leak was discovered under the vehicle. The vehicle was not diagnosed or repaired. The VIN was not included in NHTSA campaign number: 12v459000 (fuel system, gasoline). The manufacturer was notified of the failure. The approximate failure mileage was 109,000.

61 Other Fuel System problem of the 2005 Saturn ION

Failure Date: 08/12/2016

While traveling on highway, I stopped and filled up gasoline and I noticed a continuing strong gas smell in car. Thought I spilled gas on myself but later upon inspection in my garage, I found gas dripping from plastic fuel line (under car, right behind driver's door). Due to danger, I immediately set up appointment with polar Chevrolet, who decided the fuel line needed replacement. Cost was $623. 44.

62 Other Fuel System problem of the 2006 Saturn ION

Failure Date: 07/18/2016

A week ago, my car wouldn¿t start on the first try, but did start on the second. As I drove around town that day running errands (multiple stops/starts), I began to smell gas as I walked around the back of the car. The next time I drove the car was 3 days ago; every time I tried to start the car it took 2 tries, and the gas smell near the back of the car was worse. I also began to smell a strong gas smell as I loaded bags into the trunk. Yesterday, I experienced all of those issues, plus I had to drive with the windows open because the gas smell was now very bad inside the car. When I parked at the supermarket, I was able to see a small amount of gas on the rain-wet pavement, coming from just ahead of the rear driver side tire. The progression of the leak was fast - over 7 days, and only about 70 miles driven (I drive <5,000 mi / yr). I went online to research the problem, and found gm recall #090226 / NHTSA campaign id# 09v419000, which perfectly describes what¿s happening. I¿m planning to call gm tomorrow about this, but I expect to be disappointed, since my car was not purchased or registered in any of the states listed in the recall. It shouldn't matter where I bought or registered my Saturn; if my car demonstrates the same defect, the repair should be covered by gm. I also found a scary number of complaints on various websites from other Saturn owners who are experiencing the same problems, but are also not included in the recall. How many is ¿enough¿ for gm to expand the recall? gm's failure to address * of the cars affected by this problem is appalling and dangerous.

63 Other Fuel System problem of the 2007 Saturn ION

Failure Date: 07/11/2016

The contact owns a 2007 Saturn Ion. While the vehicle was stationary, the fuel lines rusted without warning. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the issue. The failure mileage was 109,000.

64 Other Fuel System problem of the 2004 Saturn ION

Failure Date: 06/24/2016

The contact owns a 2004 Saturn Ion. When the vehicle was taken to an independent mechanic for routine maintenance, the technician stated that there was a leak in the fuel line. The vehicle was not repaired. The VIN was not included in NHTSA campaign number: 04v281000 (fuel system, other). The manufacturer was notified of the failure. The approximate failure mileage was 105,000.

65 Other Fuel System problem of the 2003 Saturn ION

Failure Date: 06/01/2016

The contact owns a 2003 Saturn Ion. The contact stated that the odor of fuel was present outside the vehicle. The cause of the failure was not diagnosed. The vehicle was not repaired. The manufacturer was not notified of the failure. The VIN was invalid. The failure mileage was 152,000.

66 Other Fuel System problem of the 2006 Saturn ION

Failure Date: 05/15/2016

Re the 2013 fuel system recall. Parts cracked and fuel leaked. Gm recalled and promised to replace system. My vehicle began leading in may of 2016. I brought it to the dealer where it has sat for one month. Dealer unable to get fuel filler assembly part 15918244 from gm and gm making no promises about fixing it or getting the part. They have said the problem may or may not ever be resolved. They claim the supplier may be able to supply by mid-August. Then they updated it to maybe in September. In the meantime, I have to rent a car with no end in sight. Can;t get definitive answer from gm regarding if or when part will be delivered.

67 Other Fuel System problem of the 2006 Saturn ION

Failure Date: 04/16/2016

There is a very strong smell of fuel - sometimes when driving, but most often after turning the vehicle off - inside and outside of the passenger compartment and inside the trunk. I believe it may also be leaking a small amount of gasoline. The smell is very strong and definitely noticeable, and I am concerned that if there is in fact a leak in the fuel system somewhere, that a fire may start from a stray spark, etc. There is a recall for 2006 Saturn Ions sold and registered in arizona and nevada due to for possible cracks in the plastic supply or return port on the modular reservoir assembly (NHTSA campaign 09v419000). My car was bought and registered in illinois, so it does not apply. Why would cars in all 50 states not be covered - if it has to do with heat, I would think that you would be more concerned for vehicles in states that have variable temperatures, since that could cause plastic to crack, too. I am the original owner of the vehicle - which has low mileage for its age - and I have tried to maintain my vehicle so I can continue to drive it for as long as possible. This is not caused by me, but a known manufacturing defect and should be fixed by the manufacturer at no cost.

68 Other Fuel System problem of the 2006 Saturn ION

Failure Date: 04/08/2016

I am starting to smell fuel and the fuel system has developed a slow leak.

69 Other Fuel System problem of the 2003 Saturn ION

Failure Date: 04/04/2016

The contact owns a 2003 Saturn Ion. When the contact started the vehicle, he smelled fuel and noticed a significant amount of fuel on the ground. The manufacturer stated there were no recalls available. The vehicle was not diagnosed. The failure mileage was 130,000.

70 Other Fuel System problem of the 2006 Saturn ION

Failure Date: 03/25/2016

Takata recall,,,I have been smelling fuel from my car about 2 weeks,,I took it to an automotive for diagnostic and they told me and gave me a print out of a recall that was sent July 2015,,this I never received, so I called a gm place where I prev had my recall done and said that my VIN number is not recalled for this problem! they said that all 2006 Saturn Ions are not the same, since my VIN # is not part of this recall they wont fix m y car,,,I dont understand , I am smelling fumes not only when I drive , but hours later it still smells. They said I could bring it in for 300. Oo diag. And then pay to have it fixed!! can you explain this to me please!?.



Fuel Economy of ION Vehicles
ION Service Bulletins
ION Safety Recalls
ION Defect Investigations