Other Fuel System Tank Assembly problems of the 2019 Toyota RAV4 - part 2

Stated capacity of fuel tank is 14. 5 gallons. Even when absolutely close to empty ("20 miles left in tank"), the most I can fill up tank is 9 to 10 gallons. Advertised range of vehicle is 500 miles. I'm lucky if I get 400 miles from a single tank.

The car claims 14. 5 gallon tank. You can only put 10 gallons in the tank. If you put more, it spills all over the ground. Instead of a range of 560, it only has a 400 mile range. This has happened multiple times over the past month. If the tank show half full, you can only put in 4. 3 gallons.

The tank does not hold the "full" gas capacity that the tank is meant to hold. I am only able to put about 9 gallons of gas into the tank. The SUV has a gas tank of 14. 5 gallons and yet I have never been able to fuel anywhere close to that. It has been happening since I bought the car on 09/09/19.

When pumping gas the auto-off feature is clicking early, causing me to only fill between 9-10 gallons of the 14. 5-gallon tank. I've seen a lot of reports of this issue and would like to make my own claim here as well. I own a 2019 Rav4 xle hybrid.

Unable to refuel more than 10 gallons of fuel from empty for a gas tank that takes 14. 5 gallons.

Unable to completely fill the fuel tank. Stops abut 4 gallons short. Happens on every fill. I have to trickle fill it to get close to a full tank. Happens at each fill up.

Gas tank is rated at 14. 5 gallons. But it can only accept 9-10 gallons when I fuel up well after the low fuel light.

Unable to fill gas tank beyond 9. 5 gallons even though the car has a 14. 5 gallon tank. Gas light was on and car estimating 35 miles to empty when I filled it. When I get back in the car my fuel gauge shows that the tank is full. I'm averaging about 350 miles per tank right now.

Fueling: gas pump shut off when tank is about have full. To complete fueling I have to pull gas hose out of tank and place nozzel where I can see gas being deposed into tank to complete fill. I have had gas spray back on me. Takes 3 times as long to fill.

While feeling the gas, at almost emtpy, I didn,'t went above the 10 gallons. This requiered me to go multiple times to the gas station to fill io the gastank. Moreover, the gas range has decreased from almost 500 miles to less than 380 miles in range from 2 months ago till now. The milage of the vehicle is less around 2,800 miles. Vehicle was bought in August of 2019.

When fueling my Rav4 hybrid I am not able to completely fill the tank.

I bought my bought a 2019 Toyota Rav4 hybrid a couple months ago. I like it for the most part, but one of the primary reasons I bought it was for the advertised ~550 mile range. However, every time I've put in a full tank, the �mile range� at the front dash shows around 430 miles. I got the tank replaced by atlantic Toyota in west islip but my tank is only getting 9 gallons of fuel when the tank is 14. 5 gallons. 2019 Toyota Rav4 hybrid xle awd.

Purchased 2019 Toyota Rav4 this November and I have an issue with the gas tank. It only fill 80% of the tank not completely full. When trying to fill manually to the full gauge the gas overflows and spills which creates gas spill on the side of the car and floor. This is an issue that Toyota needs to address ASAP.

Fuel tank does not fill up to advertised capacity. Consistently less than full when gas pump clicks off. Multiple pumps and gas stations have been used.

The reported gas tank size of my 2019 Rav4 limited purchased in August 2019 is rated for 14. 5 gallons. On each occasion of low fuel, warning or less than 50 miles before empty notice, each fill up has resulted in ten gallons or less. 13 Sep - 528. 6 miles driven fill up was 9. 485 gals range 534. Mpg = 55. 7 25 Sep - 418. 7 miles driven fill up was 10. 185 gals range 579. Mpg = 41 7 oct - 460. 8 miles driven fill up was 10. 343 gals range 585. Mpg = 44 18 oct - 430 miles driven fill up was 10. 058 gals range 577. Mpg = 42. 7 28 oct - 423. 5 miles driven fill up was 9. 619 gals range 560. Mpg = 44 7 Nov - 420. 5 miles driven fill up was 10. 071 gals range 545. Mpg = 41. 7 16 Nov - 309. 3 miles driven fill up was 7. 808 gallons range 539. Mpg = 39. 6 25 Nov � 382. 7 miles driven fill up was 10. 685 gallons range 568. Mpg = 35. 8 the tank size as indicated does not equate to the need to refill to capacity of 14. 5 gallons. Where or what has happened to the 4. 5 gallons of tank fuel that we seem to not being able to access?.

Battery does not fully charge, when I use the ev mode it will drain the battery to having only 3 green lines and wont want to access the ev mode saying battery is too low. This takes about 10 min to drain. When I go put gas I usually try to fill up the tank. I leave the pump on so it can fill automatically. At one time it clicked to where it indicates its full. When I went to drive off I noticed that the fuel indicator was lower than full tank. I though it was the gas pump. Went again to fuel up and did the same thing but this time I had to stand there to fuel up myself this time it took more gallons then it should have taken. So there is something defiantly wrong with the intake tank of this Rav4.

Toyota is knowingly selling and not repairing a potentially non-compliant vehicle. I purchase a 2019 Toyota Rav4 xse hybrid and Toyota did not disclose that there was a gas tank issue. Toyota is false advertising that gas mileage and continuing to sell the 2019 and 2020 Rav4 hybrids with the same gas tank issue. The gas tank will not fill to its advertised capacity and it is not get the advertised mpgs. It has a 14. 5 gallon tank but will only take 9 gallons on empty. And I have only been getting 30 mpg and the advertised is for 41mpg. Toyota is aware of the problem and have been aware for about a year now and has not fixed the problem. I have taken my car in and I was told there is no fix. I opened a case with Toyota and have yet to be reached out to so I can get the problem resolved. I purchased this car because of the gas tank and mpgs and now I purchased for nothing, this tank and mpg issue should have been disclosed at the time of purchase so I would have had the right to make a decision to purchase or not.

The gas tank does not fill all the way, so I have having to go back and pump more gas into the tank. This sometimes can lead to overflow and the gas leaking to the ground and can be hazards.

Gas tank size is 14. 5 gal. But only fills up to 9 gal.

I can only get about 10 gallons in this 14. 5 gallon tank. The gas pumps clicks off at 3/4 full. I bought this car for the advertised range of about 500-550 and it is no where near that. Toyota is well aware of the problem as there are hundreds of complaints online about this same problem. I do not understand how some cars have the problem and apparently some do not.

The gas tank will not fill up. If it is dead empty, the most we can get the tank to except is 10 gallons. The vehicle is suppose to except 14. 5 gallons. Because of this issue, we are having to fill the tank up more often. The vehicle specs state it should get 507 miles per tank and we get around 400 miles per tank.

Bought new from dealer in 10/19. 14. 5 gal fuel tank will not accept more than 9. 8 gallons even after ~20 miles after it shows 0 miles of range. This leaves 3-4 gallons (>120 miles of range) unavailable!! not as advertised. Toyota is aware, but doing nothing!!!.

Gas tank does not fill fully. Only fills to 10 gallons each time I fill it up, which only gives me around 400 miles of driving.

My fuel tank is 14. 5 gallons and it will not allow more then 9. 5 gallons into it even when vehicle has been run down to empty. This has been consistent since purchasing the vehicle in August. The tank size and mpg are incorrect in regards to what was advertised.

My 2019 Toyota Rav4 hybrid xle (purchased in CA) will not allow a full fuel tank fillup. Once the �empty� warning comes on, the 14. 5 gallon tank will only accept about 9 to 10 gallons before shutting off. Even if you slowly �trickle� the gas in, it shuts off before 11 gallons are in. Car is not providing anywhere near the average estimated driving range of approximately 560 miles, as advertised by Toyota. This reduces credibility of the Toyota fuel status warning, making it more likely drivers may run out of fuel on busy freeway or remote highway. I have reported it to the dealership, and to Toyota national customer service and received a case #.

The fuel tank was at maximum capacity when picked up from the dealer with an estimated range of ~550 miles. Since driving away from the dealer, I have never been able to add more than 9-10 gallons into the "14. 5" gallon tank, even well after the "low fuel" light has come on. Even with extra topping off and the needle reads as close to full as I can get it, now the estimated range tends to be ~350-370 miles. I have filled up the tank about 10 times now and this outcome is consistent.

I cannot completely fill up the gas tank. When the gauge shows empty, I can only get 9-10 gallons in. The specs say it has a 14. 5 gallon tank, but it is impossible to get that much fuel into the tank. The cruising range is less than 400 miles, far less than what is advertised. I've been calling the dealership and Toyota corporate since October 2019 and am still being told that "Toyota is investigating it".

Mte, gallons to fill up, don't equal the miles to go after a fill up. Have had car a year, have only filled up once more than 10 or so gals, doesn't matter how many miles to empty show on gauges. Don't get anywher near the miles driven that was told to me. I fill up, usually takes about 9-10 GLS. Will have less than 500 miles to drive on that tank of gas. Driving local and on highway.

Only able to put 9 or 10 gallons into the gas tank when the fuel gauge was indicating empty. The tank is supposed to have a 14. 5-gallon capacity. Factory refuses to offer any consideration for this annoying issue.

Tl the contact owns a 2019 Toyota Rav4. The contact noticed that the vehicle would only fill up to three fourths of a tank with fuel as opposed to the full twelve gallons that should be required. The contact took the vehicle to magic Toyota (21300 hwy 99, edmonds, wa 98026, 206-395-9200) where it was diagnosed that the vehicle was not reaching its full fuel capacity. The dealer was aware of the failure, but did not have a remedy. The manufacturer was notified and provided case number: 1910072815. The contact informed the manufacturer that he would look into having the vehicle purchased back due to the failure. The vehicle had not been repaired. The failure mileage was 350.

The fuel tank will not fill up completely. When the fuel gauge is reading empty the fuel tank will only accept 8-9 gallons of fuel. The fuel tank is 14. 5 gallons. To try and fill the tank I have to repeatedly try to top it off. This happens every time I try to refuel.

Toyota's 2019 Rav4 limited hybrid boasts of having a 14. 5 gallon fuel capacity. When I fill my tank, I can fill it to 10 gallons maximum. The service advisor, aaron england, insists that this is normal. He stated that no cars can be filled to capacity. I am not wanting to fill to capacity. Toyota is not acknowledging this is inaccurate and says my car either has 3-4 gallons, but the sensor can not detect it or I have a tank smaller than claimed. They will not investigate. When fueling my vehicle, it stops fueling when a little more than an 1/8 of a tank shows remains until full. Online, there is much evidence from other owners that this is an issue and Toyota is refusing to offer help.

Unable to fill tank to capacity. Tank holds 14. 5 gallons but I can only get at most 10 gallons in when range of less than 40 miles and gauge reads less than a quarter of a tank. At 40 miles to the gallon, there should be room for 13. 5 gallons. Range only increases to not more than 475 miles when "full" when I should get 550 as advertised. I bought the car in August and have had the same experience at the gas station with 4 fill ups. Looks like many 2019 hybrid Rav4 owners are having the same problem. I complained to the dealer who claimed to never have heard of this.

Fuel tank does not fill up to maximum and leaves about 3-4 gallons short. This has been occurring since late 2019. I've brought this us to the dealership several times, but nothing has been done.

You can't fill it up all the way it shuts off and is not full by several gallons. One time we tried putting the fuel in very slowly and it overfilled the tank and spilled out! it has been impossible to fill up since purchase.