Suspension Problems of Toyota RAV4 - part 2

This car was bought for a new driver and we have had 2 separate occasions when she has gotten somewhere and the car wont start. All the warning lights come on, but will not do anything when you push the button. We can jump it and it will start. This is not safe for a young person that could get stranded at random somewhere, and is now afraid to take it somewhere. We have checked the connections and the battery has been checked and is fine. The other complaint is the rear suspension recall. The tires were rotated and now it has a vibration, I was told that because of the recall it cannot be aligned unless things are replaced because of the terrible fix job on the recall. If something is recalled it should be fixed correctly and not be a bandaid job. There should not be a cost associated with a cheap fix that caused more problems. We purchased this vehicle because of reputation, if they are not supporting their product, then it will go and no other Toyota products will be purchased.

See all problems of the 2010 Toyota RAV4 🔎.

I had been noticing since November 2020 a strange noise from the rear on the driver side anytime I parked the car, as it goes over a step about 2 inches in height when entering it. I took it to the dealer an explained them that it wasn't just the noise but that I could move with my hands the rear tire on the driver side back and forth. They told me no problem found. Also, that day I did have a wheel alignment done just in case. But I returned days later as it was not balance, the steering felt incorrect pulling right and left. And they tell me that the right front lower control arm needs replacement when the car has been driven 23,062 miles; I replaced it but the steering was still incorrect. I called Toyota (800) 331-4331 a case #210730001337 was opened. I was told to buy 3 new tires to correct the problem, I did it, yet the problem continues. I expected the dealer to do a wheel alignment after replacing the tires yet they lie about and they wanted me to drive away, I refused to do it and called Toyota and offered to pay for it and finally they agreed on doing it free and they found out that the rear alignment was off. Poor craftsmanship of the rear suspension parts for sure. That weird noise on the rear continues, the steering pulls right and left which increases risk of losing control and eventual crash and injury. I do trust the NHTSA to make things right do not be like boeing and the faa.

See all problems of the 2018 Toyota RAV4 🔎.

The contact owns a 2008 Toyota Rav4. The contact stated while driving at various speeds, the vehicle failed to drive in a straight line and would erroneously drift out of the lane. The vehicle was taken to the local dealer who diagnosed that the rear suspension was faulty and needed to be repaired. The contact indicated that the vehicle was previously repaired under NHTSA campaign number: 16v596000 (suspension) however, the failure occurred. The vehicle was not repaired. The approximate failure mileage was 157,000.

See all problems of the 2008 Toyota RAV4 🔎.

Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? yes, while driving on the interstate the vehicle began vibrating heavily. What component or system failed or malfunctioned, and is it available for inspection upon request? upon inspection it was noticed that the inner tread of the left rear tire was damaged, worn away and scalloped or cupped. The tire was replaced with a spare, and vehicle driven to the nearest Toyota dealer for service. The damaged tire is available for inspection. Has the problem been reproduced or confirmed by a dealer or independent service center? yes, the servicing dealer informed us that the left rear camber was out of manufacturer specification being -1. 8 deg. The minimum allowed is -1. 7, and the minimum recommended is -1. 3. We were informed that to be safe the vehicle required repairs; however, they were unable. We then took the vehicle to the selling dealer who also found the issue and were unable to repair. Two additional service centers also confirmed the rear camber was out of specifications, and posed a safety risk. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? yes, the dealer stated that a manufacturer representative from Toyota inspected the vehicle. How was your safety or the safety of others put at risk? safety was compromised as the damage to the tire was severe and hidden. This damage could have resulted in a loss of control of the vehicle. The vehicle remains in the unsafe condition. It is also important to note that the tires were being rotated every 5,000 miles by a manufacturer service center as recommended.

See all problems of the 2019 Toyota RAV4 🔎.

My 2021 Toyota Rav4 have design problems with suspension system. Where if the freedom over 55mph the car will be unstable, bumpy and shaky. I am really scared to drive my car on the hwy. I heard mist 2021 Rav4 have the same problem. Toyota needs to have a recall to fix or change suspension system with a firm one ASAP. Thank you.

See all problems of the 2021 Toyota RAV4 🔎.

My problem is upon inspection of the vehicle I was told a recall (16v596000) for my rear suspension arms was available and I needed to have it done as the back end nuts couldn't be adjusted. I called a dealership and was told this was taken care of 3 years ago, yet the problem still remains.

See all problems of the 2009 Toyota RAV4 🔎.

Had an alignment performed at tire discounters. Afterwards they informed me that the vehicle front right camber was out of specs. They attempted to bring specs within oem but unable to. Required to purchase camber kit from Toyota to perform necessary adjustments. Vehicle only has 14,000 miles.

Car vibrate at certain speed. Suspects faulty front lower suspension arm. Vehicle show symptoms after third service (Toyota care -15000 miles).

Struts are making a lot of noise in the rear of the car, also heat shield grommets are loose and produces a banging sound under the car. All the noises are noticeable while driving at low speeds. Torque converter and 6 solenoids had to be replaced.

See all problems of the 2013 Toyota RAV4 🔎.

As a result of having recall 16v596000 performed, rear toe arms are no longer adjustable for alignments. Contacted Toyota customer experience and was told they would not repair at their cost the manufacturing defect that causes premature rust, offered no solutions. Causes premature tire wear, loss of traction.

See all problems of the 2006 Toyota RAV4 🔎.

Good afternoon! I just notice today the rear suspension is very rusty. I would like to know if is any recall in this car. Thanking in advance for helping in this matter.

See all problems of the 2004 Toyota RAV4 🔎.

On 7/3/20 at about 3 pm edt I was preparing to turn left and exit my neighborhood. I was stopped. I pressed on the accelerator and the vehicle suddenly accelerated straight ahead at a high rate of speed. I was unable to stop the vehicle. I travelled about 100 to 150 feet, climbed an enbankment and landed in a small wooded ravine. I was attempting to exit my neighborhood onto a paved road.

Tl - the contact owns a 2020 Toyota Rav4. The contact received notification of NHTSA campaign number:20v286000(suspension) however, the parts needed to perform the remedy were unavailable. The local dealer stapp Toyota located at 8019 raspberry way, frederick, CO 80504 was contacted regarding the matter where it was confirmed that the part was not available. The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The manufacturer was not yet contacted. The contact had not experienced a failure. Parts distribution disconnect. Jft.

See all problems of the 2020 Toyota RAV4 🔎.

When turning right the car has a knocking noise.

I received 2 speeding camera tickets due to sudden acceleration noticed time to time, front suspensions are not even and rough, transmission is not smooth when changing gears and/or stopping vehicle.

When driving my car everytime I make a turn there is a noise coming from the shock of the wheels front and rear I took it to the dealership 3 times and they said they hear nothing then I took it to my mechanic and he said it's the ball bearing on top of the shock. Now the noise is getting louder and louder, I'm scared something will happen to me and my family when we are all in the car. So please can you guys help me out.

Auto burning excessive oil and coolant box stays full to top car is stationary.

While driving straight down the highway the there was a pop sound in the back of the vehicle and I was unable to maintain control of the vehicle. This lead to the Rav4 coming to a stop after impaling on guardrail from freeway speeds. Upon inspection it appeared that the rear left wheel was the cause and was at an angle instead of being perpendicular to the ground like the rest of the wheels.

See all problems of the 2007 Toyota RAV4 🔎.

Tl the contact owns a 2020 Toyota Rav4. The contact stated that upon purchasing the vehicle, the power steering was loose and became difficult to maneuver the vehicle while driving at various speeds. She also stated that the steering wheel pulled to the left while driving at various speeds. The vehicle was taken to tom wood Toyota (6408 crane dr, whitestown, in 46075) on three occasions where the alignment was adjusted however, the failure persisted. The contact then took the vehicle to andy mohr Toyota (8941 e us hwy 36, avon, in 46123) where the vehicle was diagnosed with a missing front toe link. The vehicle was repaired however, the failure persisted. She then took the vehicle back to andy mohr Toyota for the second time where the mechanic manually adjusted the steering wheel however, the failure persisted. The manufacturer was notified of the failure. Upon investigation, the contact linked her failure to NHTSA campaign number: 20v286000 (suspension) however, the VIN was not included. The vehicle was not repaired. The failure mileage was 60.

I have fixed my rear suspension more than 4x and it continues to go bad, it works fine for a couple of weeks but still not running well then it shocks and goes back to bouncing whenever it hits a bump or anything not smooth on the roads. It happens when driving and you feel it a lot more when it's running on local roads. The visibility is bad, the defogger does not work and I have to wait about 15-20 mins or open the window. When I put my hands on the vent for the defogger there is no air coming from it.

See all problems of the 2011 Toyota RAV4 🔎.

Tl- the contact owns a Toyota Rav4. The contact stated while driving 30 mph the vehicle wobbled, and the contact was unable to control the vehicle. The contact stated no warning lights illuminated before the failure. The vehicle was taken to bob tyler Toyota located at (7201 pensacola blvd, pensacola, FL 32505) were the vehicle recall was completed. The contact stated the rear towing rod broke off the vehicle. The vehicle was towed to vannoy's tires located at (3425 gulf breeze pkwy, gulf breeze, FL 32561) and both tow rods bars were replaced. The manufacturer was notified of the failure. The approximate failure mileage 104,000 bh.

The straps that hold the gas tank up rotted out and off.

See all problems of the 2001 Toyota RAV4 🔎.

The contact owns a 2006 Toyota Rav4. The contact received notification of NHTSA campaign number: 16v596000 (suspension), however the parts for the recall remedy were not available. The contact stated that the manufacturer exceeded a reasonable amount of time to repair the vehicle. Heritage Toyota catonsville (6324 baltimore national pike, baltimore, MD 21228, (844) 315-0964) was contacted and confirmed that parts were not available. The manufacturer was not notified. The contact had not experienced a failure. The VIN was not available.

Rear suspension fix of previous recall will not allow rear alignment of vehicle because of the epoxy encasement. This is not acceptable. Just spent 800. 00 on tires and alignment only to find out the rear is out of alignment and can't be aligned due to Toyota's fix (epoxy encasement).

Toyota has been claiming I have no open recalls and I learn I have two. They can not locate my VIN to remedy my issues . . . Since I've own the vehicle in three states, and again now here in wisconsin. My vehicle body is literally falling apart (on its own!) and I can't repair it or get recalls rectified. It's a 2007 with under 70k mikes! I paid for an extended warranty and they did nothing but oil changes which I paid for.

Recall csj was performed 08/01/14. Rear toe-in set at 0. 10. On 08/28/19 dealer found rear toe at 0. 08 left and 0. 25 right and reported it as "failed". Then informed us that alignment can't be corrected due to recall csj and we should drive the vehicle "as is' or pay for replacement rear tie rods. Recall gov was not performed. The vehicle has increased steering sensitivity. .

Tl- the contact owns 2006 Toyota Rav4. The contact stated that both rear wheel are wearing out the tires due to a recall on the rear suspension arm NHTSA campaign number: 16v596000 (suspension) which was seal and was completed at naguabo auto sales dealer, (272 naguabo pr 00718). The contact stated that an alignment could not be completed due to the seal on the rear suspension that the dealer was supposed to replaced both suspension arm but was seal instead. The contact also stated that the tires would slide while driving. The vehicle was taken back to the same dealer and was informed an alignment could not be completed due to the seal on the rear suspension. The vehicle was not repaired. The manufacturer was made aware of the failure and did not assist. The failure mileage was approximately 182,999. Aw.

The tires sleeps to the front when you try steering to the sides ether right or left and the tires make horrible noice and the slip to the front and if you don't brake when the car slip to the front you can hit the vehicle infront of you, looks like they make the steering angle to wide or the tires turn too much that instead of making a turn they sleep to the front and thats too dangerous because it can cause an accident.

2010 Toyota Rav4. Consumer writes in regard to warranty enhancement program and feels the company and dealership should cover warranty work.

Installed rear lower suspension arms (non-adjustable rear toes) in 2014 per recall campaign #16v596000. Tire vendor said rear alignment was off in 2016 (when replacing new tires) and could not be adjusted or replaced with adjustable toe due to recall sticker. Dealer inspected toes 2016 and said specs are right and tire vendor does not have right specs. Since 2016 I have replaced 4 tires twice within 50,000 miles even though tires have longer 50,000 mile warranties. The tires have lasted less than half of their expected lifetime. In 2019, tire vendor said rear alignment is off again when replacing tires and can't be adjusted due to recall sticker. This suggests that the rear toes inserted in 2014 for safety recall created a new problem - poor alignment which causes premature wearing of tires. I'm requesting permission to replace non-adjustable rear toes with adjustable ones so that I don't have to keep prematurely replacing my tires.

El veh�culo hace un ruido en ambos lados DE las puertas del conductor y pasajero, entre las puertas, dash y guardalodos. El ruido ES como un restrillar cuando el veh�culo cae en un hoyo, toma un bad�n o hace fricci�n al frenar.

Rear suspension arm (tie rods) fixed under recall campaign 13v 383000 have become loose. After several calls to the manufacturer and to two different dealers, Toyota has denied to help with the cost of repairs. Obviously their recall "fix" has not worked and I think they should be held responsible for the repairs due to this fact.

Tl- the contact owns a 2009 Toyota Rav4. The contact stated while driving various speeds they heard abnormal noises coming from the rear. The independent mechanic diagnosed the vehicle and stated that the rear differential needed to be repaired. No warning lights illuminated. The vehicle had not been repaired. The manufacturer was made aware of the failure. The failure mileage was 112,000. Nd.

Tl the contact owns a 2008 Toyota rav 4. The contact received notification of NHTSA campaign number: 16v596000 (suspension). The contact stated that the manufacturer exceeded a reasonable amount of time for the recall repair. The dealer was not contacted. The manufacturer was made aware of the issue and was not able to confirm when the parts were to become available. The contact had not experienced a failure. Parts distribution disconnect.

Sometimes when I am pulling out or pulling in to park my car I hear this bang on my right rear side. Sometimes when I am turning left or right and the right rear tire gets most of the weight of the vehicle I hear the same hard bang. I took it to my mechanic and he rode with me and he heard it too. My mechanic thought it was the struts and replaced them, but that was not the problem. I still have this problem. Please help. My mechanic said that under the car in the rear there is a bar that has a stamp that indicates recall item.