Volkswagen Passat owners have reported 39 problems related to front suspension (under the suspension category). The most recently reported issues are listed below. Also please check out the statistics and reliability analysis of Volkswagen Passat based on all problems reported for the Passat.
While attempting to make a 180-degree turn, coming from a parked position on the street, the front left wheel disconnected from the car and hung at a 90-degree angle. This car is dangersou when super-extending the suspension system because a hollow knuckle is used in the suspension system.
See
all problems of the 1999 Volkswagen Passat
🔎.
Vwofa does not acknowledge that this is a widespread problem on both Audi a4 and vw Passats even though there is overwhelming evidence that there is a design flaw. This problem should be covered under warranty since it is a defect in design/workmanship. No safety defect.
See
all problems of the 1998 Volkswagen Passat
🔎.
Steering pulls to the right and always has, mostly during braking, the rotors need to be replaced while the front brakes are at 20%, steering problems possibly due to the faulty rotors.
Car had been recalled for repairing defective tie rod - once fixed the entire front end and tires have gone bad and the dealer estiimates $ 1500 for repairing tires. Manufacturer is adamant and obnoxious and thinks that this is normal wear and tear based on telephone conversation. At 38,000 miles front end failure needs to be investigated.