Chrysler Aspen owners have reported 41 problems related to other fuel system (under the other fuel system category). The most recently reported issues are listed below. Also please check out the statistics and reliability analysis of Chrysler Aspen based on all problems reported for the Aspen.
Significant fuel spit-back occurs upon every refueling.
See
all problems of the 2008 Chrysler Aspen
🔎.
The contact owns a 2007 Chrysler Aspen. The contact stated that while refueling, fuel ejected from the vehicle. The contact also stated that the check engine light illuminates intermittently. The vehicle was not taken to a mechanic. The vehicle was not repaired. The manufacturer was not contacted. The failure mileage was approximately 65,000.
See
all problems of the 2007 Chrysler Aspen
🔎.
Every time I fuel up gas overflows spilling onto my vehicle and ground.
Vehicle has been overflowing gas at the end of fillup. The pump shuts off as it should, but then gas overflows out. We are not topping off - this happens with the first shutoff of the gas pump. This at first happen periodically, but now happens every time, no matter where I am filling up. I am not over filling the vehicle by any means, in fact I can slow the pump down to a dribble and it will still "burp" out fuel all over the side of the vehicle and leaving a large puddle of gas on the ground. This is a huge safety issue and needs to be delt with by Chrysler. I have talked to others personally that have the same issue and have read that many many others are having this same issue.
On this date and at least a few others our Aspen unintentionally accelerated. It usually accelerates from a dead stop after the SUV is shifted into drive with foot on the brake pedal. It will also occasionally accelerate when slowing down before coming to a stop. Chrysler dealerships have no solutions since service managers have had no previous experiences with this problem. So they say.
Tl- the contact owns a 2007 Chrysler Aspen. The contact stated while refueling the vehicle spewed fuel back. There are no warning indicators illuminate prior or during the failure. The vehicle was not taken to the taken to the dealer or independent mechanic to get it diagnosed. The vehicle's gas cap was replaced however in the early stage of the failure. The manufacturer was not made aware of the issue. The vehicle failure mileage was 105,000. Kh.